Eagle Tracker 3000 - Reminders; Operational Safety

Eagle Solutions, ©2008, Tracker Operator Manual Page #8
Eagle Solutions, ©2008, Tracker Operator Manual Page #9
• Operator must have completed certication
trainingbeforeusingmachine.
• Propermaintenanceistheresponsibilityofthe
operatorbeforeuseofmachine.Thisincludes:
checking the oil level, checking and cleaning
airanddustlters,keepingmachinecleanand
lubricated,inspectfordamaged,wornorloose
parts,cleancarburetorairlters(andasneeded
during operation), clean entire machine after
eachuse.
• Sweepoorandcheckforitemsprotrudingout
oftheoorsurfacebeforeoperatingmachine.
• Do not start engine with the transport wheel
attached,ifapplicable.
• Donotallowthemachinetorununattendedor
betiltedbackwhileitisrunning.
• ExhaustpartsareextremelyHOT.Becareful
not to allow them to come into contact with
anythingoranyone.
• Do not attempt to change pads or abrasives
whiletheengineisrunning.
• Exercise extreme caution when installing
or changing pads or abrasive material.The
machineisveryheavy!
• Maintainproperroomventilation.
• Donotstandonthemachine.
• Stoptheenginebyclosingtheservicevalveon
thefuelcylinder.
• Removethekeyfromtheswitch,ifapplicable,
topreventunauthorizeduse.
• Removethefuelcylinderfromthemachineand
storeitoutsideinasecureapprovedcabinet.
• Servicingoradjustingthepropanefuelsystem
should only be done by a trained service
technician.Never attempt to adjust the fuel
systemof a propane engine!If equipped with
an emission monitoring or controlling system
neverattempttodisconnectitorcircumventit!
• Neverattempttobypassordisconnectthekill
switchoranyothersafetydevices.
• Liqueed propane will expand 270 times to
ammable vapor - avoid needless release
of liqueed propane and using overlled
cylinders.
• Propaneisheavierthanair–ifitleaksitwill
spreadinlowplaceslikeunderdoorswhereit
maybeignitedandcausedamage.
• Only use 4E240 cylinders that are approved
bytheDOT-neverusecylindersdesignedfor
otherserviceslikebarbecues.
• The low boiling point of propane can cause
serious frostbite – always wear frost proof
gloves and a face shield before attempting to
checkforfuelcylinderoverll.
• Incaseofare,keepthefuelcylindercoldwith
anextinguisherorwaterhose.
• Store fuel cylinders vertically in an outside
lockable,ventilatedstoragelocker.
• Beawareofthesymptomsofcarbonmonoxide
poisoning and take appropriate actions if
necessary.
• Always maintain engine and mach
ine as
specied for superior performance, long life
andsafety.
Reminders
Operational Safety
To Order Parts Call 1-888-702-5326 - https://monsterfloorequipmentparts.com