Emerson White Rodgers 36H Series - Precautions; General Safety Warnings; Installation Precautions; Handling and Usage Cautions

3
1. Failuretoturnoelectricormaingassup-
ply to heating system could cause personal
injury and/or property damage by shock, gas
suocation,re,and/orexplosion.
2. Donotusethiscontroloncircuitsexceeding
speciedvoltage.Highervoltagewilldam-
agethecontrolandmaycauseshockorre
hazard.
3. NEVER USE FLAME OR ANY KIND OF SPARK
TO CHECK FOR GAS LEAKS–COULD CAUSE
FIRE AND/OR EXPLOSION.
4. DO NOT USE WIRE JUMPER on any pilot
systems, such as standing pilot, proven/in-
termittent pilot, or spark-to-pilot ignition–a
reand/orexplosionmayresult.
Ifyoudonotfollowtheseinstructionsexactly,areorexplosion
may result, causing property damage, personal injury or loss of life.
5. Donotuseacontrolsetfornaturalgaswith
LPgas,oracontrolsetforLPgaswithnatural
gas. Personal injury and/or property damage,
gassuocation,re,and/orexplosionmay
result.
6. Do not use a gas valve which appears to
be damaged. A damaged valve may cause
personal injury and/or property damage
due to shock, gas suocation, re and/or
explosion.Contactsuppliertoreplaceany
valve that appears to have been damaged.
7. Do not use a gas valve that has been in direct
contactwithwater.Waterenteringgasvalve
may result in concealed internal damage to
gas valve. Personal injury and/or property
damage,gassuocation,reand/orexplo-
sion may result.
WARNING
!
DO NOT BEGIN INSTALLATION UNTIL YOU READ THE FOLLOWING
PRECAUTIONS.
WARNING
!
Properly install gas piping to control.
• Donotremoveprotectiveinletoroutletcapsuntilreadytoconnectsupplypipetogasvalve.
• Usenewsupplypipe,properlythreaded,reamed,de-burred,andcleaned.
• Usebackupwrench,appliedonlytoprovidedwrenchatsoninletboss,whentighteningthe
supply pipe. Do not grip bracket, solenoid or any other part of control.
• Donotover-tightenpipetocontrol(50 ft-lbsmax.)
• Alwaysinstallsedimenttrapinthegassupplylinetopreventcontaminationofgasvalve.
Failuretoinstallproperlycancausegasleakageresultingininjuryduetoreorexplosion.
CAUTION
!
1. Donotshortoutterminalsongasvalveorprimarycontroltotest.Shortorincorrectwiring
can cause equipment damage, property damage, and/or personal injury.
2. Thiscontrolisnotintendedforuseinlocationswhereitmaycomeindirectcontactwithwater.
Suitableprotectionmustbeprovidedtoshieldthecontrolfromexposuretowater(dripping,
spraying, rain, etc.).
3.  Cleangaspipingofcontaminants,cuttinguid,orotherchemicalswhichmightreactharm-
fullywiththegasvalvecomponentsbeforeinstall.
PRECAUTIONS