EXT
RA - FLUGZEUGBAU GmbH
SERVICE MANUAL EXTRA 200
CHAPTER 05
PAGE 13
PAGE DATE: 1. July 1996
Inspector:
Mechanic:
Date:
Serial No.:
Inspections
as specified
each 50 hours
each 100 hours
O O Inspect Christen Inverted Oil System for general condition,
leaks, secure mounting and tight connections.
O
1
13 Clean and flush the Inverted Oil System with a suitable
petroleum solvent, such as varsol according to Lycoming
Operators Manual.
O O 14 Service engine with recommended lubricating oil in accord-
ance with Chapter 12-10-04.
O O 15 Inspect condition of spark plugs (Clean and adjust gap as
required, adjust per Lycoming Service Instruction 1042). If
fouling of spark plugs has been apparent, rotate bottom plugs
to upper plugs and vice versa.
O O 16 Inspect spark plug cable leads and ceramics for corrosion and
deposits.
O O 17 Perform a hot engine differential compression check in
accordance with FAA AC 43.13-1A.
O 18 Inspect cylinders for cracked or broken fins.
O O 19 Check cylinders for evidence of excessive heat which is
indicated by discoloration.
O 20 Check fuel injector nozzles for looseness. Tighten to 60 inch
pounds torque. Check fuel lines for fuel stains which are
indicative for fuel leaks.
O O 21 Inspect rocker box covers for evidence of oil leaks. If found,
replace gasket; torque cover screws 50 Inch-pounds.
O
2
22 Remove rocker box covers and check for freedom of valve
rockers when valves are closed. Look for evidence of abnor-
mal wear or broken parts in the area of valve tips, valve
keeper, springs and spring seats.
O 23 Inspect ignition harness for general condition, free from
fraying or chafing and insulators for high tension leakage and
continuity.
SCHEDULED MAINTENANCE CHECKS
Maintenance Checks Schedule
1 each 300 hours
2 each 400 hours
To Next Page
Loading...
