Fagor ADVANCE CONCEPT - Installation Checks; Electrical Installation Checks

16/11/2012
28
1. Checking installation
1. Checking installation1. Checking installation
1. Checking installation
YES
YESYES
YES NO
NONO
NO
a) Is the floor level?
a) Is the floor level?a) Is the floor level?
a) Is the floor level?
If “NO”, what is the difference in level?
If “NO”, what is the difference in level? If “NO”, what is the difference in level?
If “NO”, what is the difference in level? ...........................................
......................................................................................
........................................... %
%%
% (max. 2%)
(max. 2%)(max. 2%)
(max. 2%)
b) Is there any source of heat at less than 500 mm from the oven?
b) Is there any source of heat at less than 500 mm from the oven?b) Is there any source of heat at less than 500 mm from the oven?
b) Is there any source of heat at less than 500 mm from the oven?
If “Yes”, the installation of heat protection is obligatory.
If “Yes”, the installation of heat protection is obligatory.If “Yes”, the installation of heat protection is obligatory.
If “Yes”, the installation of heat protection is obligatory.
c) Is there any other equipment at less than 500 mm from the oven?
c) Is there any other equipment at less than 500 mm from the oven?c) Is there any other equipment at less than 500 mm from the oven?
c) Is there any other equipment at less than 500 mm from the oven?
If “Yes”, what type of equipment?
If “Yes”, what type of equipment? If “Yes”, what type of equipment?
If “Yes”, what type of equipment? .....................................................................
..........................................................................................................................................
.....................................................................
d) Has a hood/extractor system been installed?
d) Has a hood/extractor system been installed?d) Has a hood/extractor system been installed?
d) Has a hood/extractor system been installed?
e)
e) e)
e) For gas ovens without an extraction system, has the draught diverter been
For gas ovens without an extraction system, has the draught diverter been For gas ovens without an extraction system, has the draught diverter been
For gas ovens without an extraction system, has the draught diverter been
installed?
installed?installed?
installed?
If “YES”, is the pipe Ø equal to 280 mm?
If “YES”, is the pipe Ø equal to 280 mm?If “YES”, is the pipe Ø equal to 280 mm?
If “YES”, is the pipe Ø equal to 280 mm?
f) Is there a FAGOR extractor hood installed?
f) Is there a FAGOR extractor hood installed?f) Is there a FAGOR extractor hood installed?
f) Is there a FAGOR extractor hood installed?
If “Yes”, what model is it?
If “Yes”, what model is it?If “Yes”, what model is it?
If “Yes”, what model is it? ……………………………………
…………………………………………………………………………
……………………………………
What is the serial No?
What is the serial No?What is the serial No?
What is the serial No?……………………………….
……………………………….……………………………….
……………………………….
g) For floor models (201, 202), is there enough space for the trolley?
g) For floor models (201, 202), is there enough space for the trolley?g) For floor models (201, 202), is there enough space for the trolley?
g) For floor models (201, 202), is there enough space for the trolley?
h) Is the oven level?
h) Is the oven level?h) Is the oven level?
h) Is the oven level?
i) For table top models (061, 101, 102), is the table level?
i) For table top models (061, 101, 102), is the table level? i) For table top models (061, 101, 102), is the table level?
i) For table top models (061, 101, 102), is the table level?
j) For floor models, (201, 202), is the oven trolley level and adjusted?
j) For floor models, (201, 202), is the oven trolley level and adjusted?j) For floor models, (201, 202), is the oven trolley level and adjusted?
j) For floor models, (201, 202), is the oven trolley level and adjusted?
2. Electrical Installation
2. Electrical Installation2. Electrical Installation
2. Electrical Installation
a) What voltage is shown on the registration plate?
a) What voltage is shown on the registration plate? a) What voltage is shown on the registration plate?
a) What voltage is shown on the registration plate? ………
………………
……… AC /
AC /AC /
AC / …………..
…………..…………..
………….. V /
V /V /
V / …….
…….…….
……. Hz
HzHz
Hz
b) What voltage is available at the installation?
b) What voltage is available at the installation? b) What voltage is available at the installation?
b) What voltage is available at the installation? .……...
.……....……...
.……... AC /
AC /AC /
AC / ……….….
……….….……….….
……….…. V /
V /V /
V / …….
…….…….
……. Hz
HzHz
Hz
c) Measured voltage at the installation:
c) Measured voltage at the installation:c) Measured voltage at the installation:
c) Measured voltage at the installation:
Phase 1
Phase 1 Phase 1
Phase 1 –
––
– Phase 2 ____________V Phase 1
Phase 2 ____________V Phase 1 Phase 2 ____________V Phase 1
Phase 2 ____________V Phase 1 –
––
– Neutral ____________V
Neutral ____________VNeutral ____________V
Neutral ____________V
Phase 1
Phase 1 Phase 1
Phase 1 –
––
– Phase 3 ____________V Phase 2
Phase 3 ____________V Phase 2 Phase 3 ____________V Phase 2
Phase 3 ____________V Phase 2 –
––
– Neutral ______
Neutral ______Neutral ______
Neutral _______
__
______V
_____V_____V
_____V
Phase 2
Phase 2 Phase 2
Phase 2 –
––
– Phase 3 ____________V
Phase 3 ____________V Phase 3 ____________V
Phase 3 ____________V Phase 3
Phase 3 Phase 3
Phase 3 –
––
– Neutral _____
Neutral _____Neutral _____
Neutral ______
__
_______V
______V______V
______V
Neutral
Neutral Neutral
Neutral –
––
– Earth ____________V
Earth ____________VEarth ____________V
Earth ____________V
d) Electrical consumption by phase:
d) Electrical consumption by phase:d) Electrical consumption by phase:
d) Electrical consumption by phase:
Phase 1
Phase 1Phase 1
Phase 1 ……....
……....……....
…….... A Phase 2
A Phase 2A Phase 2
A Phase 2 ……….
……….……….
………. A Phase 3
A Phase 3A Phase 3
A Phase 3 ……….
……….……….
………. A
AA
A
YES
YESYES
YES NO
NONO
NO
e) Are there any electrical
e) Are there any electrical e) Are there any electrical
e) Are there any electrical protections in the installation?
protections in the installation?protections in the installation?
protections in the installation?
If “Yes”, what types?
If “Yes”, what types?If “Yes”, what types?
If “Yes”, what types?
Magneto
MagnetoMagneto
Magneto thermal
thermal thermal
thermal …….
…….…….
……. A Fuses
A FusesA Fuses
A Fuses …….
…….…….
……. A
A A
A D
DD
Differential
ifferentialifferential
ifferential …….
…….…….
……. mA
mA mA
mA (300 mA)
(300 mA)(300 mA)
(300 mA)
f) Can the electrical panel be accessed by the user?
f) Can the electrical panel be accessed by the user?f) Can the electrical panel be accessed by the user?
f) Can the electrical panel be accessed by the user?