FLOJET 18555-000 - User Manual

FEATURES
• Connects directly to the RV waste outlet
• Eliminates 3" (75 mm) sewer hose
• Garden hose discharge port
• Fresh water rinse capabilities
• Remote handheld on/off switch with
6' (1.8 m) wire harness and fuse
• Ability to dump longer distances
• Ability to drain holding tanks at home
• Easy clean up and storage
• Rugged portable storage case
• USCG and CSA listed
SPECIFICATIONS
Pump: Self-Priming Flexible Impeller with
Stainless Steel Wearplate
Impeller: Jabsco Nitrile Compound
Macerator: Stainless Steel Cutter reduces particle
size to 1/8" (4 mm) maximum
Seal: Lip Type
Ports: Inlet – 3" (75 mm) RV Connector
Outlet – Garden Hose – see table
Motor: 12 Vdc Permanent Magnet Type,
Fully Enclosed, with Stainless Steel Shaft
Intermitent Duty Only
Weight: 6 lb (2.8 kg)
Case Size: 12" x 13" x 5.5"
(300 mm x 315 mm x 140 mm)
This pump should be used in accordance with EPA
Sanitation Regulations.
Model 18555-000
PORTABLE RV WASTE PUMP
SELF-PRIMING MACERATOR
Hose Size Maximum Hose Length
5/8” (16 mm) 25 feet (7.5m) max
3/4” (19 mm) 50 feet (15m) max
RECOMMENDED HOSE TABLE
APPLICATION
The Flojet 18555-000 DC portable waste pump is the
ideal solution for emptying holding tanks on recreational
vehicles and avoiding dump stations. The macerator
section grinds waste down to a particle size of
1/8" maximum so it can easily be pumped through a
garden hose. Empties a typical 40-gallon holding tank in
less than 5 minutes. Do not run more than 15
minutes continuously.
The 18555-series waste pump will macerate and pump
all waste and tissue normally found in recreational
vehicle waste systems. IT WILL NOT HANDLE HARD
SOLID OBJECTS, SANITARY NAPKINS OR RAGS.
Recommended lengths are based on horizontal
discharge. Longer discharge runs create higher
resistance and may result in the pump motor over
heating.
DO NOT MOUNT PERMANENTLY
TO THE RV WASTE PORT.
DO NOT RUN DRY FOR MORE
THAN 30 SECONDS.

Summary

Wiring Diagram and Electrical Instructions

Wiring Diagram

Illustrates the electrical connections for the portable RV waste pump, including power source and switch.

Electrical Instructions

Details on connecting the pump's wiring, power source, and fuse replacement for the 12 VDC system.

Pump Operation and Maintenance

Operating Instructions

Step-by-step guide for using the portable waste pump, including tank emptying and rinsing procedures.

Impeller Release Feature

Procedure for freeing a stuck impeller after periods of non-use using a screwdriver.

Disassembly and Assembly Procedures

Disassembly

Detailed instructions for taking apart the pump, including removing specific components like the chopper blade and wearplate.

Assembly

Instructions for reassembling the pump, focusing on seal installation, wearplate positioning, and securing components.

Warranty and Product Information

Easy to Use

Describes the simplicity of using the waste pump for emptying holding tanks into a sewer receiver.

One Year Limited Warranty

Outlines the terms and conditions of the limited warranty, including coverage, exclusions, and liability limitations.

FLOJET 18555-000 Specifications

General

Brand	FLOJET
Model	18555-000
Category	Water Pump
Language	English