FOG 442 9020 - General Vehicle Lift Safety Instructions

444 9160 / 444 9180 / 442 9020
9
E 219 GB - Issue 1
General Vehicle Lift Safety Instructions:
An uneven distribution of load on the front and back pick-up platforms should not exceed the listed
ratio of the types: 444 9160 and 444 9180 at a capacity of 3000 kg 3 to 2
442 9020 at a capacity of 3500 kg 2 to 1
The vehicle must always rest on all 4 supporting pads.
The vehicle must be picked up at the points stipulated by the manufacturer.
The vehicle and the lift must be observed during all vertical movements.
While the lift is operated, the danger area must be kept free. Travelling on or climingup on the
lift is not permitted. Persons under the age of 18 must not operate the lift.
The safety devices must not be changed in their position or function.
Repairs should only be carried out by authorised specialists.
The statutory accident prevention rules must be adhered to.
No work must be carried out on the vehicle during vertical movements.
The nominal load shown on the lift must not be exceed.
After a brief lifting of the vehicle it should be checked that all lifting arms are securely bolted.
If necessary, the vehicle should be lowered again and by a slight oscillating movement of the
lifting arm the bolt should slip into place.
During assembly and dismantling of vehicle units the eccentricity of the centre of gravity must
be taken into account.
Take care when vehicles are loaded! (other total weight and weight displacement)
If the safety instructions are not observed there is a
danger of injury!
Danger