FRICK QUANTUM™ CONDENSER/VESSEL CONTROL PANEL S90-555 M
MAINTENANCE Page 61
CONVENSER/VESSEL RECOMMENDED SPARE PARTS
QUANTUM™ CONTROL PANEL
Part Numbe
Description Spare-1 Spare-2 Spare-3
649D4824H01 Display cable (Quantum™ 4, see chart below) yes
649C1091G04 Main Pentium processor circuit board (Quantum™ 4) yes
649C1092G04 Main Pentium processor circuit board (Quantum™ 3) yes
649C1078H01 10.4"diag. LCD color VGA display assembly with backlight yes
649B0862H01 Wire Harness Adapter (Quantum™ 4) yes
649A0883H10 Circuit Breaker, 10A yes
640D0060H01 Keypad/overlay yes
640B0065H01 Display Cable (Quantum™ 3 & LG Phillips display, see chart below) yes
640B0049H01 AC Power Cable Harness for Quantum™ yes
640B0048H01 Power Cable Harness, I/O, DC, Condor yes
640B0045H01 Display Cable (Quantum™ 3 & Sharp display, see chart below) yes
640B0032H01 Back light (CCFT) inverter cable (Quantum™ 3) yes
640B0031H01 Keypad cable yes
640C0039H02 Cable Harness, Power yes
333Q0001637 DC Power Supply, Condor yes yes
333Q0001582 Inverter, for Sharp & LG Phillips yes
333Q0001418 Corcom RF Line Filter yes yes yes
333Q0001649 On/off power switch contact block yes yes
333Q0001764 On/off power switch yes yes
333Q0001786 Battery, 3V, Varta # CR2032
REMOTE PANEL
Part Numbe
Description Spare-1 Spare-2 Spare-3
649B0776H01 HOA Switch Module, 120 v (Optional) yes
649A0883H03 Circuit Breaker, 3A (Optional w/Heater) yes
649A0883H10 Circuit Breaker, 10A yes
640D0117H01 Control, GCU Board yes
640D0062H01 Digital Input/output circuit board (Optional) yes
640C0056H01 Wire Harness, DC Power, Condor GSC25A Power Supply yes
640B0066H01 Wire Harness, Power & Comm. To Digital Board (Optional) yes
640B0060H01 DC Power Supply, Condor yes yes
640B0059H01 Wire harness , AC power yes
640C0049H01 Wire harness , DC power yes
333Q0001179 Heater, Flex, 150W, 120VAC, Built-in thermostat (Optional) yes
333Q0000116 Input Module 120 volt AC yes yes yes
111Q0281061 Output Module 120/240 volt AC yes yes yes
Note 1 – These processor boards are listed for reference. Each Quantum™ Control will have only one of these
boards. Order only the replacement board that is applicable to your controller, not both boards.
Spare-1 - Normal spare parts kept on hand. Operation can wait more than 24 hours to receive replacement parts.
Spare-2 - Additional spare parts kept on hand. Operation must have parts in less than 24 hours.
Spare-3 - Critical operation. Plant must have continuous operation.
DISPLAY ASSEMBLY COMPONENT REPLACEMENT GUIDE
DESCRIPTION
MANUFACTURER
SAMSUNG
NEC
(OBSOLETE)
SHARP LG PHILIPS
(CURRENT)
10.4” TFT Display 333Q0001180 333Q0001494 333Q0001581 649C1078H01
Backlight Inverter
333Q0001582 (OR
333Q0001181)
333Q0001495 333Q0001582 333Q0001582
Cable - CPU to Display (Quantum™ 3) 640B0036H01 640B0043H01 640B0045H01 640B0065H01
Cable - CPU to Inverter (Quantum™ 3) 640B0032H01 640B0044H01 640B0032H01 640B0032H01
Cable - CPU to Display/Inverter (Quantum™ 4) 649D4824H01 SEE NOTE "A" 649D4824H01 649D4824H01
Replacement - Backlight Not Available 333Q0001587 333Q0001588 333Q0001785
Display Replacement Assy. 640C0021G01
640C0021G01
Rev (A)
640C0021G01
Rev (B)
640C0052G01
NOTE : When upgrading from a Quantum™ 3 with an NEC Display, to the Quantum™ 4, the display will need to be upgraded also.
Order 640C0052G01 to replace the display. The LK4 jumper will need to be in the "A" position.
To Next Page
Loading...
Need help?
General
