Frymaster FPRE314 - default chapter; Table of Contents

i
RE Series E
4
Electric Fryers
Installation and Operation Manual
TABLE OF CONTENTS
CHAPTER 1: Introduction
1.1 General Information ..........................................................................................................1-1
1.2 Safety Information.............................................................................................................1-1
1.3 Computer Information.......................................................................................................1-2
1.4 European Community (CE) Specific Information.............................................................1-2
1.5 Installation, Operating and Service Personnel ..................................................................1-2
1.6 Definitions......................................................................................................................... 1-2
1.7 Shipping Damage Claim Procedure ................................................................................. 1-3
1.8 Service Information...........................................................................................................1-3
CHAPTER 2: Installation Instructions
2.1 General Installation Requirements.................................................................................... 2-1
2.2 Power Requirements..........................................................................................................2-3
2.3 Positioning the Fryer Station.............................................................................................2-3
CHAPTER 3: Operating Instructions
3.1 Setup and Shutdown Procedures.......................................................................................3-2
3.2 Controllers......................................................................................................................... 3-3
CHAPTER 4: Filtration Instructions
4.1 Draining and Manual Filtering..........................................................................................4-1
4.2 Preparing the Built-In Filtration System for Use ..............................................................4-2
4.3 Operation of the Filter.......................................................................................................4-5
4.4 Disassembly and Reassembly of the Magnasol Filter.......................................................4-7
4.5 Draining and Disposing of Waste Oil ............................................................................... 4-8
CHAPTER 5: Preventive Maintenance
5.1 Cleaning the Fryer............................................................................................................. 5-1
5.1.1 Daily Checks and Service..................................................................................................5-1
5.1.3 Weekly Checks and Service.............................................................................................. 5-2
5.1.4 Boiling Out the Frypot .....................................................................................................5-2
5.2 Monthly Checks and Service............................................................................................. 5-3
5.2 Calibration of Solid State (Analog) Controller Knob .......................................................5-3
5.3 Annual/Periodic System Inspection ..................................................................................5-3
CHAPTER 6: Operator Troubleshooting
6.1 Introduction ...................................................................................................................... 6-1
6.2 Troubleshooting................................................................................................................. 6-2
6.2.1 Troubleshooting Controller and Heating Problems .......................................................... 6-2
6.2.2 Troubleshooting Error Messages and Display Problems ..................................................6-4
6.2.3 Troubleshooting the Basket Lift........................................................................................ 6-7
6.2.4 Troubleshooting the Built-In Filtration System ................................................................ 6-7