Gardner Denver ELECTRA-SAVER EAY99G - Index

13-10-617 Page 6
INDEX
Addition Of Oil Between Changes ...................52
Aftercooler Piping.............................................50
Air Filter............................................................65
Air Filter Vacuum Switch..................................35
Air Filter, Section 6...........................................65
Air Flow In The Compressor System .................9
Air-Cooled Units, Location ...............................15
Airsmart™ Operation .......................................29
Auxiliary Air Receiver.......................................18
Blowdown Valve...............................................32
Blowdown Valve Piping....................................19
Check
Daily..............................................................26
Cold Ambient Operation...................................52
Cold Weather Operation ..................................17
Cold Weather Operation, Installation For.........17
Compression Principle .......................................9
Compressor........................................................9
Compressor Bearing Oil Filter..........................56
Compressor Capacity Control - Turn Valve .....37
Compressor Main Oil Filter Instructions...........57
Compressor Oil Cooler - Water-Cooled Heat
Exchanger ....................................................59
Control Devices................................................29
Control Piping...................................................18
Controller..........................................................29
Controls & Instrumentation, Section 4 .............29
Cooling, Sealing And Lubrication.....................10
Coupling ...........................................................67
Daily Check ......................................................26
Discharge Service Line ....................................19
Discharge Thermistor.......................................36
Drain
Oil Reservoir.................................................16
Draining And Cleaning Oil System...................54
Electrical Wiring ...............................................22
Emergency Stop Push-Button..........................36
Enclosure .........................................................16
Fan Starter .......................................................36
Filling Oil Reservoir..........................................55
Filter Element ...................................................65
Foundation .......................................................16
Fuse Blocks......................................................36
General Information, Section 1 ..........................9
Grounding.........................................................22
Heat Exchanger (Oil) Piping.............................51
High Temperature Operation ...........................46
Inlet Line...........................................................18
Inlet Screen And Tube .....................................66
Inlet Valve ........................................................33
Installation For Cold Weather Operation .........17
Installation, Section 2.......................................14
Lifting Unit........................................................14
Location ...........................................................14
Air-Cooled Units ...........................................15
Water-Cooled Units......................................16
Lubricant
Recommended.............................................45
Lubricant Change Procedure...........................52
Lubrication
Motor ............................................................23
Lubrication, Cooling And Sealing.....................10
Lubrication, Oil Cooler, Oil Filter & Separator .45
Main Starter .....................................................36
Maintenance Schedule, Section 8 ...................70
Minimum Discharge Pressure Valve................32
Moisture In The Oil System .............................46
Moisture Separator/Trap..................................18
Motor Lubrication .............................................23
Oil Change Interval ..........................................53
Oil Cooler - Radiator Type...............................58
Oil Level Gauge .........................................32, 53
Oil Reservoir ....................................................60
Oil Reservoir Drain...........................................16
Oil Separator
Compressor (GD Eliminator)........................61
Inspection.....................................................62
Oil Carryover ................................................61
Pressure Differential Gauging......................62
Removal For Inspection Or Replacement....62
Oil Specifications .............................................45
Oil System
Compressor..................................................45
Draining And Cleaning .................................54
Oil System Check ............................................63
Air And Oil Discharge Temperature .............63
Oil Cooler Oil Pressure Differential (Air-
Cooled Radiator) ......................................63
Oil Cooler Oil Pressure Differential (Water-
Cooled Heat Exchanger) ..........................63
Oil Cooler Temperature Differential (Air-
Cooled Radiator) ......................................64
Oil Cooler Temperature Differential (Water-
Cooled Heat Exchanger) ..........................64
Oil Cooler Water Pressure Differential (Water-
Cooled Heat Exchanger) ..........................64
Oil Inlet Pressure..........................................63
Oil Inlet Temperature ...................................63
Operation
High Temperature ........................................46