Genesis 320 - User Manual

56511 09/17/10 NG
US ENGLISH
#56511
320/330
Guía del Propietario de la Barbacoa de Gas Natural - Pg. 29
Guide de l’utilisateur du barbecue au gaz naturel - Pg. 53
ESNA
GAS GRILL
Natural Gas Grill Owner’s Guide
YOU MUST READ THIS OWNER’S GUIDE
BEFORE OPERATING YOUR GAS GRILL.
m DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
m WARNING:
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
m WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
m WARNING: Do not ignite this appliance
without first reading the BURNER
IGNITION sections of this manual.

Genesis 320 Specifications

General

Brand	Genesis
Model	320
Category	Grill
Language	English

Summary

Safety and Operational Precautions

DANGER: Gas Leak Safety Procedures

Critical steps to take if gas is smelled, including shutting off supply and evacuation.

WARNING: Leak Check and Ignition Safety

Importance of leak checks before operation and safe ignition practices.

Critical Warnings and Safety Advisories

DANGER: General Hazard Warnings

Potential for serious injury or death from non-compliance with manual instructions.

WARNING: Propane Cylinder Handling

Natural Gas Installation Guide (Model 320)

Gas Supply Piping Specifications (Model 320)

Requirements for natural gas piping, connectors, and hoses.

Testing Gas Connections for Leaks

Method for safely checking all gas connections for leaks before use.

Natural Gas Installation Guide (Model 330)

Gas Supply Piping for Model 330

Specifications for natural gas piping and connections for the 330 model.

Leak Testing for Model 330 Connections

Steps for safely testing gas connections on the 330 model.

Understanding Your Natural Gas Grill

Natural Gas Fuel and Connection

Information on natural gas and how to connect the supply hose to the grill.

Leak Check Preparation Steps

Performing Gas Leak Detection

Control Panel Removal for Leak Testing

Soap and Water Leak Detection Method

Procedure for using soap solution to identify gas leaks.

Post Leak Check and Reassembly

Verifying All Gas Connections

Detailed checks for specific gas line connections after leak testing.

Pre-Use Grill Inspection and Checks

Igniter and Hose Condition Inspection

Main Burner Ignition and Usage

Electronic Ignition System Operation

Step-by-step guide to ignite main burners using the electronic system.

Manual Main Burner Ignition Procedure

Lighting Main Burners with a Match

Sear Station Operation (Model 330)

Igniting the Sear Station Burner

Comprehensive Grill Troubleshooting

Main Burner Operational Issues

Solutions for common problems like yellow flames, no ignition, or low heat.

Side Burner Operational Issues

Troubleshooting steps for issues with the side burner not lighting or low flame.

Grill Cleaning and Maintenance

General Grill Cleaning Instructions

Burner Tube and Panel Service

Burner Tube Cleaning and Replacement Guide

How to clean or replace the grill's burner tubes.

Burner Tube Service Procedures

Burner Tube Removal and Cleaning Steps

Detailed instructions for removing, cleaning, and reinstalling burner tubes.

Reinstalling Burner Tubes and Wires

Electronic Ignition System Troubleshooting

Checking Electronic Ignition Components

Igniter Module Wiring Diagrams