Greenheck SP-6 User Manual

Page 1
MODEL SP-6
WARNING
TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR IN-
JURY TO PERSONS, OBSERVE THE FOLLOWING:
1. Use this unit only in the manner intended by the manufacturer. If
you have questions, contact the manufacturer at the address or
telephone number listed in the warranty.
2. Before servicing or cleaning unit, switch power off at service panel
and lock the service disconnecting means to prevent power from
being switched on accidentally. When the service disconnecting
means cannot be locked, securely fasten a prominent warning
device, such as a tag, to the service panel.
3. Installation work and electrical wiring must be done by a quali-
fied person(s) in accordance with all applicable codes and stan-
dards, including fire-rated construction codes and standards.
4. Sufficient air is needed for proper combustion and exhausting of
gases through the flue (chimney) of fuel burning equipment to
prevent backdrafting. Follow the heating equipment
manufacturer’s guideline and safety standards such as those
published by the National Fire Protection Association (NFPA),
and the American Society for Heating, Refrigeration and Air Con-
ditioning Engineers (ASHRAE), and the local code authorities.
5. When cutting or drilling into wall or ceiling, do not damage elec-
trical wiring and other hidden utilities.
CEILING
VENTILATOR
READ AND SAVE THESE INSTRUCTIONS
Installer: Leave this manual with the homeowner.
Homeowner: Use and Care information on page 4.
WARNING
6. Ducted fans must always be vented to the outdoors.
7. If this unit is to be installed over a tub or shower, it must be
marked as appropriate for the application and be connected to a
GFCI (Ground Fault Circuit Interrupter) - protected branch cir-
cuit.
8. Never place a switch where it can be reached from a tub or
shower.
9. This unit must be grounded.
CAUTION
1. For general ventilating use only. Do not use to exhaust hazard-
ous or explosive materials and vapors.
2. To avoid motor bearing damage and noisy and/or unbalanced
impellers, keep drywall spray, construction dust, etc. off power
unit.
3. Please read specification label on product for further informa-
tion and requirements.
TYPICAL INSTALLATIONSTYPICAL INSTALLATIONS
16”-ON-CENTER CEILING JOISTS
Housing mounted directly to joist.
24”-ON-CENTER CEILING JOISTS
Housing mounted to additional framing.
!
HOUSING
CEILING
JOIST
MOUNTING TABS
GRILLE
CEILING
MATERIAL
POWER CABLE
HOUSING
CEILING
JOIST
MOUNTING TABS
GRILLE
CEILING
MATERIAL
POWER CABLE
4" ROUND
DUCT
ADDITIONAL
FRAMING

Greenheck SP-6 Specifications

General

Brand	Greenheck
Model	SP-6
Category	Fan
Language	English

Summary

READ AND SAVE THESE INSTRUCTIONS

General Safety Warnings

Safety warnings to reduce the risk of fire, electric shock, or injury to persons.

Operating Cautions

Cautions for general use, hazardous materials, and motor bearing protection.

Typical Installation Diagrams

Diagrams illustrating typical installations for 16" and 24" on-center ceiling joists.

INSTALL THE HOUSING

Suspended Ceilings Installation

Instructions for mounting housing with wires in suspended ceilings using a 3-point mount.

New Construction Installation

Steps for choosing location, positioning mounting brackets, and securing housing in new construction.

Existing Construction Installation

Steps for choosing location, tracing outline, and cutting ceiling opening for existing construction.

INSTALL THE HOUSING (continued)

Existing Construction Securing

Securing housing in existing construction opening and alternative mounting methods.

INSTALL THE DUCTWORK

Ductwork Connection

Instructions for connecting the damper/duct connector and 4" round duct to the unit.

ATTACH THE GRILLE

Grille Mounting

Steps for attaching the grille using spring tabs and optional tabs.

CONNECT THE WIRING

Wiring Diagram and Procedure

Wiring diagram and instructions for connecting electrical cable to the unit.

USE AND CARE

Service and Cleaning Precautions

Important precautions for disconnecting power before servicing and note on motor lubrication.

Cleaning Instructions

Instructions for cleaning the grille and fan assembly using mild soap and water.

WARRANTY INFORMATION

Warranty Details

Details Greenheck Fan Corporation's one-year warranty for defects in material and workmanship.

SERVICE PARTS

Parts List

List of available service parts with part numbers and descriptions.