Himoinsa STANDARD - Hazard Prevention; Towing Safety

SAFETY REGULATIONS | PAG. 5
2.3 SAFETY AGAINST THE DANGER OF FIRE
• Always refuel the tank of the gen-set, in a ventilated area with the
engine completely switched off.
• Do not ll the fuel tank of the gen-set when it is running or with the
engine hot.
• Fill the fuel tank to a maximum 90% of its total capacity. Make sure
that the cap of the tank is perfectly closed.
• Check that no fuel has been spilt on the gen-set. If this happens, you
must clean it and let it dry well, before starting the equipment. The
leftover fuel could ignite.
• Diesel is ammable and its vapours explosive. It is forbidden to
spoke, use a naked ame or produce sparks while refuelling or using
the equipment.
• Do not place ammable objects or materials close to the engine
while running and refuel.
• Do not place anything on the air inlet /outlet area and on the exhaust
outlet as this could cause the overheating of the engine and may
create a re hazard.
• Do not place anything on the spotlight immediately after use,
because they come to reach very high temperatures.
2.4 SAFETY AGAINST BURNS
• Never touch the engine or the gen-set exhaust while is running or
some minutes after its stop, it can cause severe burns. Before
handling and maintenance service, let the engine cools down.
• Never touch the halogen lamps during 20-25minutes after its use,
can cause severe burns.
2.5 SAFETY IN THE TOWING
Towing a lighting tower requires care. Both trailer and vehicle must be in good
conditions, and securely fastened to reduce the possibility of accidents. Some
countries, requires the trailer be registered and licensed. Contact the Trafc
• Lower the mast if strong winds (more than 80km/h) or thunderstorms
are expected in the area.
• The tower extends up to 9m. Make sure area above it is open and
clear of overhead wires and obstructions.
• If for any reason any part of the mast hangs up or the winch cable
develops slack while raising or lowering the tower, STOP immediately
and contact with the Technical Department at HIMOINSA.
• Make sure that chains, hooks, ramps, jacks and any other type of
lifting devices are attached securely and have enough counterweight
to lift and hold the equipment safely. Remain aware of the position of
other people around you when lifting the mast.
• NEVER remove the safety lock or pull the locking pin while the mast
is up.
• NEVER adjust the mast when the unit is in operation.
• NEVER turn on the lights without the protection glass cover placed or
with a cracked or damaged glass.
IMPORTANT
Always put the support skids for achieving a secure and perfect stability of the
lighting tower with the help of the spirit level.
2.2 SAFETY AGAINST THE DANGER OF ELECTROCUTION
• Never handle the lighting tower and its gen-set with wet hands of feet.
If the tower is stored outside, check that the engine and alternator
are dry. Dry them if they are wet.
• Never touch bare wires or disconnections. Keep electrical wires and
connections in good condition.
• Always use the suitable plugs for the outlet bases provided on
the generator set. Never use zinc or cables without a plug or with
stripped ends. Introducing these cables directly into the outlet socket
could create a high risk of electrocution.
• As soon as you notice any cable in a poor condition, replace it and
make sure it is in perfect condition before switching on the lighting
tower again.