Hobart FT1000 - Automatic Soil Removal (ASR) System Cleaning

– 11 –
1. Followingthechemicalmanufacturer’sinstructions,prepareamixtureofdelimer
andwater,andpourorbrushthesolutionontothesurfacetobecleaned.
2. Allowtosoakfor10minutes.Ifrequired,scrubtoremoveheavydeposits.
3. Rinsethoroughlywithfreshwater.
Automatic Soil Removal Section (When Equipped)
MachinesequippedwithAutomaticSoilRemoval(ASR)featureanadditionalsection
locatedimmediatelyaftertheloadendofthemachine.Duringmachineoperation,
theASRsectioncapturesfoodsoilandpumpsittotheexternalscrapbasket,located
beneaththeloadofthemachine.
Toemptytheexternalscrapbasketduringmachineoperation,removethebasket,
emptyandreplace.ThemachinewillcontinuetooperateunlesstheSTOPbuttonis
pressedattheload,unloadoronthekeypadlocatedonthefrontofthecontrolbox.
TocleantheASRsystem,removetheexternalscrapbasketlocatedbeneaththe
loadsection,emptyfoodsoil,rinsebasketinsinkandreplace.Removetheupper
andlowerASRwasharms.Toremovetheupperarm,pullbackonthetab,allow
thearmtodropandpullout.Toremovethelowerarm,pullupslightlyandpullthe
armout.Rinsebotharmsinthesinkandensureallnozzlesareclearofdebris.
RemovetheASRstrainerpan,andthenremovethetwopiecesoilcollectorstand
pipe(Fig.13).Cleanthesecomponentsusingasprayerhoseinasink.Useahose
tospraydowntheinsideoftheASRsectionaswell.
Fig. 13
Replaceallcomponentswhencomplete.Toreplacethesoilcollectorstandpipe,drop
thebottomofthetubewiththestrainerintothedrainbodylocatedatthebottomof
theASRtankandtheninstallthesoilcollectortubeontopofthepreviouslyinstalled
tube.Placethestrainerpanontop,notingthatitsitsslightlyhigherthanthetank.
Replacethelowerwasharmbyfollowingtheguiderailandpushingthetubeinto
placeinthemanifold.Replacetheupperwasharmbypushingthetubeintothe
uppermanifold,pushingupandsnappingintoplace.