Hobbico NexStar ARF User Manual

READ THROUGH THIS INSTRUCTION MANUAL
FIRST. IT CONTAINS IMPORTANT INSTRUCTIONS
AND WARNINGS CONCERNING THE ASSEMBLY
AND USE OF THIS MODEL.
HCAZ3005 for HCAA2025 V1.0Entire Contents © Copyright 2004
Champaign, Illinois
(217) 398-8970
E-mail: airsupport@hobbico.com
INSTRUCTION MANUAL
ALMOST-READY-TO-FLY RADIO CONTROLLED MODEL AIRPLANE
Wingspan: 68-3/4 in [1745mm] Length: 56 in [1420mm]
Wing Area: 722 sq in [46.6 dm
2
]
Weight: 6.25–6.75 lb [2835–3060 g]
Wing Loading: 21 oz/ft
2
[63 g/dm
2
] Radio: 4-5 channel
Engine: .46–.50 cu in [7.5–8.2cc] two-stroke
.52–.56 cu in [8.5–9.2cc] four-stroke
Hobbico
®
guarantees this kit to be free from defects in both
material and workmanship at the date of purchase. This warranty
does not cover any component parts damaged by use or
modification. In no case shall Hobbico’s liability exceed the
original cost of the purchased kit. Further, Hobbico reserves
the right to change or modify this warranty without notice.
In that Hobbico has no control over the final assembly or material
used for final assembly, no liability shall be assumed nor accepted
for any damage resulting from the use by the user of the final
user-assembled product. By the act of using the user-assembled
product, the user accepts all resulting liability.
If the buyer is not prepared to accept the liability associated
with the use of this product, the buyer is advised to return
this kit immediately in new and unused condition to the place
of purchase.
To make a warranty claim, send
the defective part or item to
Hobby Services at this address.
Include a letter stating your name, return shipping address, as
much contact information as possible (daytime telephone number,
fax number, e-mail address), a detailed description of the problem
and a photocopy of the purchase receipt. Upon receipt of the
package the problem will be evaluated as quickly as possible.
WARRANTY
Hobby Services
3002 N. Apollo Dr. Suite 1
Champaign IL 61822
USA

Hobbico NexStar ARF Specifications

General

Radio System	4-channel
Skill Level	Beginner
Airfoil	Flat-bottom
Type	Trainer
Engine Size	.40-.46 cu in (6.5-7.5 cc)
Servos	4

Summary

WARRANTY

SAFETY PRECAUTIONS

IMPORTANT SAFETY PRECAUTIONS

KIT INSPECTION

ORDERING REPLACEMENT PARTS

ASSEMBLY

Assemble the Wing

Step-by-step instructions for assembling the wing of the NexSTAR ARF model.

Install the Engine

Detailed instructions for installing the engine onto the Hobbico NexSTAR ARF model.

Alternate Engine Installation

Landing Gear Installation

Step-by-step guide for installing the main and nose landing gear on the model.

Install the Tail Surfaces

Instructions for installing the stabilizer, fin, and rudder components onto the fuselage.

Radio Installation

Guide for installing servos, receiver, and wiring in the fuselage of the model.

GET THE MODEL READY TO FLY

Charge the Batteries

Instructions for charging the transmitter and receiver batteries for flight readiness.

Check Control Direction

Adjust the Throttle

Check the Control Throws

Balance the Model

Procedure for checking and adjusting the model's center of gravity (CG).

AMA SAFETY CODE (excerpts)

ENGINE SAFETY PRECAUTIONS

Check List

FINAL PREPARATIONS

At-the-Shop Checklist

FLIGHT PREPARATION

Check the Frequency

Important safety step to ensure no radio interference at the flying site.

Check the Controls

Range Check the Radio

Tests the radio system's operational range and reliability before flying.

Fueling the NexSTAR ARF

FLYING

Taxiing

Takeoff

Flight

Landing