Electric StartertStarter Clutch
The starter motor turns when the transmission is in neutral, but does not turn with the transmission in any position except
neutral, with the side stand up and the clutch lever pulled in.
Abnormal-. Faulty side stand switch
ed with the ignition switch ON.
Burnt bulb
1
Open circuit in wire harness
Normal
t
Check the clutch switch op Abnormal-. Faulty clutch switch
Nojmal
Check the side stand switch. Abnormal-. Faulty side stand switch
I
I
-0
Open circuit in wire harness
-
Loose or poor contact of connector
Starter Motor Turns Slowly
-
Low specific gravity in battery lor dead banery)
Poorly connected banery terminal cable
Poorly connected starter motor cable
.
Faulty starter motor
.
Poorly connected battery ground cable
.
Starter Motor Turns. But Engine Does Not Turn
Starter motor is runnning backwards
-
Case assembled improperly
-
Terminals connected improperly
Faulty starter clutch
.
Damaged or faulty starter pinion
Damaged pinion gears
Starter Relay Switch "Clicks", But Engine Does Not Turn Over
-
Crankshah does not turn due to engine problems
Excessive pinion gear friction
To Next Page
Loading...
Need help?
General
