Honeywell VR8345M - Installation

3 68-0160
VR8345M
INSTALLATION
Installation
WHEN INSTALLING THIS PRODUCT…
1. Read these instructions carefully. Failure to follow
them could damage the product or cause a hazardous condi-
tion.
2. Check the ratings given in the instructions and on the
product to make sure the product is suitable for your applica-
tion.
3. The installer must be a trained, experienced service
technician.
4. After installation is complete, use these instructions to
check out product operation.
IMPORTANT: It is recommended that an appliance shutoff
valve be installed upstream of the VR8435M.
WARNING
FIRE OR EXPLOSION HAZARD
CAN CAUSE PROPERTY DAMAGE,
SEVERE INJURY, OR DEATH
Follow these warnings exactly:
1. Disconnect power supply before wiring to pre-
vent electrical shock or equipment damage.
2. To avoid dangerous accumulation of fuel gas,
turn off gas supply at the appliance service
valve before starting installation, and perform
Gas Leak Test after completing installation.
3. When working with a system using intermittent
pilot ignition, do not bend pilot tubing at gas
control or pilot burner after compression fitting
has been tightened because gas leakage at the
connection can result.
4. Always install sediment trap in gas supply line
to prevent contamination of gas control.
5. Do not force the gas control knob. Use only your
hand to turn the gas control knob. Never use any
tools. If the gas control knob does not operate by
hand, call a qualified service technician to re-
place the gas control. Force or attempted repair
can result in fire or explosion.
TABLE 3—VR8345 REPLACES THESE GAS CONTROLS.
(Continued)
Replacement Gas Controls
Universal
Old Model No. Manufacturer VR8200 VR8300 VR800 Replacement
36E36-304 DSI/HSI WHITE RODGERS VR8205A2024 VR8305M3506 VR8450A4113 VR8345M4302
a
36E36-304 IP WHITE RODGERS VR8204A2076 VR8304M3509 VR8440A3025 VR8345M4302
720-050 ROBERTSHAW VR8205A2024 VR8305M3506 — VR8345M4302
a
720-051 ROBERTSHAW VR8205A2024 VR8305M3506 — VR8345M4302
a
720-070 ROBERTSHAW VR8204A2076 VR8304A3509 — VR8345M4302
V4185A1000 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M3402
a,b
V4185A1010 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4185B1008 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4185B1016 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4185B1024 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225A1002 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225A1028 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225A1044 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225A1051 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225A1077 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225B1000 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225B1018 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
V4225B1026 HONEYWELL VR8205A2024
b
VR8305M3506
b
VR8450A4113
b
VR8345M4302
a,b
(Footnotes at end of table).