Attention
1. The diesel engine operators must familiarize themselves
with
this manual as well as engine
construction and strictly follow the procedures
of
operation
and maintenance especially the regulations for safety opera-
tion described
in
this manual.
2. Before operating
an
engine at full load
,the
60 hours running
in
should be carried
out
as
specified
in
the manual.
3. Increase its speed gradually after stating a cold engine,never
let it run
at
highs speed abruptly, and
don't
stop
the
engine
instantly while its cooling
water
is still
hot,
also
don't
let
the
engine running long
time
without
load.
4.
If
the
ambient temperature falls below +
SOC
,drain
the
cooling
water out
of
the radiator, the lubricating oil cooler and the
diesel engine itself completely after stopping the engine.
Con-
tinuous keeping the
water
in
the oil cooler should be forbid-
den.
5. Never run the diesel engine
without
and air cleaner so as
to
prevent the unfiltered air from entering the cylinders.
6. The engine
must
be filled
with
specified grade fuel and lubri-
\eating oil,and
a special
and
clean container for each oil should
be used. The fuel oil should
be settled for
72
hours and fil-
tered before using.
7. The inspection and repair
of
the components
in
electrical sys-
tem
must
be carried
out
by the person
who
has a good
knowledge
of
electricity.
8. If the
water
pump is
without
oil filler,
its
a ??? bearing wa-
.
ter
pump,
and neednt add lub oil to it.
9. Be sure
to
use
water
- cooling diesel engine. Please refer
to
P.43 for details.
10. The working environment
of
the diesel engine should be
well ventilated
to
avoid being polluted by
waste
gas or
smoke.
11.
The
power
rati~g
and
amending
of
the
diesel
engine
is
ac-
cording
to
GB6072.1"-2000 the first section
of
reciprocating
internal combustion engine:
sta"ndard
basic condition, the
To Next Page
Loading...
Need help?
General
