Husqvarna 545G Mark II Workshop Manual

Husqvarna 545G Mark II

76 pages

To Next Page

To Next Page

Page #1 background image

Loading...

Page #1 background image

Workshop manual

545 Mark II, 550 XP

®

Mark II,

545G Mark II, 550 XP

®

G Mark II

English

722 - 003 - 26.03.2019

Table of Contents

Other manuals for Husqvarna 545G Mark II

Operator's Manual44 pages

Questions and Answers:

A
Andrea ReedAug 20, 2025
Why does my Husqvarna 545G Mark II Chainsaw engine start then stop?
- B
  bullockanthonyAug 20, 2025
  Your Husqvarna Chainsaw engine may start and then stop due to several reasons. It could be due to incorrect fuel type, in which case you should drain the fuel tank and fill it with the correct fuel. Another possible cause is a clogged air filter, so you should clean or replace the air filter. Also, a clogged fuel filter could be the reason, so replace the fuel filter to resolve this.
B
Benjamin RhodesAug 22, 2025
What to do if my Husqvarna 545G Mark II engine does not start?
- J
  Jennifer RodriguezAug 22, 2025
  If your Husqvarna Chainsaw engine does not start, several factors could be the cause. The starter pawls may be blocked, requiring adjustment or replacement. Ensure the fuel type is correct by draining the tank and refilling it. Check the spark plug; it should be clean and dry. Also, make sure that the electrode gap is correct and that the spark plug is tightened. If the engine is flooded due to repeated starts with full choke, remove and clean the spark plug, lay the chainsaw on its side with the spark plug hole facing away from you, pull the starter rope handle 6-8 times, then reassemble the spark plug and attempt to start the chainsaw.
M
Michael EdwardsAug 25, 2025
Why does my Husqvarna 545G Mark II Chainsaw engine not start?
- T
  tracicampbellAug 25, 2025
  If your Husqvarna Chainsaw engine doesn't start, it might be due to several reasons. You may have used the incorrect fuel type, in which case you should drain the fuel tank and refill it with the correct fuel. The spark plug could be dirty or wet; ensure it is clean and dry. Also, check if the spark plug is loose and tighten it if necessary. If the engine is flooded due to repeated starts with full choke, remove and clean the spark plug, lay the chainsaw on its side with the spark plug hole facing away from you, and pull the starter rope 6-8 times. Then, reassemble the spark plug and attempt to start the chainsaw.
A
Allen PollardAug 26, 2025
How to fix a Husqvarna 545G Mark II when the engine does not start because of blocked starter pawls?
- S
  Steven LaraAug 26, 2025
  If the engine of your Husqvarna Chainsaw does not start, the starter pawls might be blocked. Try adjusting or replacing the starter pawls. Also, ensure the area around the pawls is clean. For further assistance, it's recommended to speak with an approved service workshop.
G
George VargasAug 27, 2025
Why Husqvarna Chainsaw engine does not start?
- G
  greerjorgeAug 27, 2025
  If your Husqvarna Chainsaw engine won't start, several factors could be at play. First, ensure you're using the correct fuel type; if not, drain the tank and refill. A dirty or wet spark plug can also prevent ignition, so clean and dry it. A loose spark plug should be tightened. An incorrect electrode gap requires using the recommended spark plug type, consulting the technical data for the correct gap. If the engine is flooded from repeated choke use, remove and clean the spark plug, lay the chainsaw on its side with the spark plug hole facing away, pull the starter rope 6-8 times, then reassemble the spark plug and try starting again. Also, check if the starter pawls are blocked; if so, adjust or clean around them, or consider replacing them.
C
Cheryl LewisAug 29, 2025
What to do if Husqvarna 545G Mark II Chainsaw starts but stops again?
- C
  Christopher GambleAug 29, 2025
  If your Husqvarna Chainsaw starts but then stops, the issue could stem from several causes. Ensure you are using the correct fuel type; if not, drain the tank and replenish with the appropriate fuel. A clogged air filter can also cause this problem, so clean or replace it. Similarly, a clogged fuel filter should be replaced. If the idle speed is incorrect, you should consult your servicing dealer.
M
Matthew WilliamsAug 31, 2025
What to do if my Husqvarna 545G Mark II engine starts but stops again?
- B
  Brian Callahan PhDAug 31, 2025
  If your Husqvarna Chainsaw engine starts and then stops, several factors could be responsible. The fuel tank may contain incorrect fuel; drain the fuel tank and fill with the correct fuel. The air filter may be dirty; clean or replace the air filter. The fuel filter may need replacing; replace the fuel filter.
S
Sean NelsonSep 1, 2025
How to fix a loose spark plug on a Husqvarna Chainsaw?
- D
  David YoungSep 2, 2025
  If the spark plug on your Husqvarna Chainsaw is loose, tighten the spark plug.
M
mwilliamsSep 3, 2025
What to do if my Husqvarna Chainsaw starts but stops again?
- H
  Haley ThomasSep 3, 2025
  If your Husqvarna Chainsaw starts and then stops, the issue might be related to the fuel or air supply. Make sure you're using the correct fuel type; if not, drain the tank and refill with the correct fuel. A clogged air filter could also be the culprit; try cleaning or replacing it. Similarly, a clogged fuel filter can cause this problem, so replace the fuel filter.
K
Kaylee DavidSep 5, 2025
Why does my Husqvarna Chainsaw engine start but stops again?
- K
  Kimberly Chavez MDSep 5, 2025
  If your Husqvarna Chainsaw engine starts but then stops, the fuel tank might contain incorrect fuel. In this case, drain the fuel tank and refill it with the correct fuel. Other potential solutions include cleaning or replacing the air filter and replacing the fuel filter. If the idle speed is not correct, consult your servicing dealer.

Husqvarna 545G Mark II Specifications

General

Brand	Husqvarna
Model	545G Mark II
Category	Chainsaw
Language	English

Related product manuals

Preview: Husqvarna 545 Mark II

Husqvarna 545 Mark II

Preview: Husqvarna 525LS Mark II

Husqvarna 525LS Mark II

Preview: Husqvarna 550XP Mark II

Husqvarna 550XP Mark II

Preview: Husqvarna 562XP Mark II

Husqvarna 562XP Mark II

Preview: 550XPG Mark II TrioBrake

550XPG Mark II TrioBrake

Husqvarna 550 XP Mark II

Preview: Husqvarna 550XP G Mark II

Husqvarna 550XP G Mark II

Preview: Husqvarna 120 Mark II

Husqvarna 120 Mark II

Preview: Husqvarna 135 Mark II

Husqvarna 135 Mark II

Preview: Husqvarna 130 Mark II

Husqvarna 130 Mark II

Preview: Husqvarna H130 Mark II

Husqvarna H130 Mark II

Preview: Husqvarna 120e MARK II

Husqvarna 120e MARK II