88
PROCEDURE 2 SAFETY INSPECTION/MAINTENANCE/TROUBLESHOOTING
S
A
F
E
T
Y
I
N
S
P
E
C
T
I
O
N
This Procedure Includes the Following:
Safety Inspection Checklist
Maintenance
M
A
I
N
T
E
N
A
N
C
E
*NOTE: This includes the manually engaged brake on ALL
scooters AND the hand brake on the PANTHER MX-4
(Before 10/00)ONLY.
NOTE: Every six (6) months take the scooter to a qualified dealer for a thorough inspection and servicing.
Regular cleaning will reveal loose or worn parts and enhance the smooth operation of the scooter. To operate
properly and safely, the scooter must be cared for just like any other vehicle. Routine maintenance will extend
the life and efficiency of the scooter.
Initial adjustments should be made to suit your personal body structure and preference. Thereafter follow
these maintenance procedures:
ITEM INITIALLY INSPECT/ADJUST
WEEKLY MONTHLY PERIODICALLY
GENERAL
Scooter drives straight (no excessive drag/pull to one side). X X
BRAKE*
Does not bind or interfere with travel. XX
Brake easy to disengage/engage. XX
UPHOLSTERY (PROCEDURES 5 AND 6 OF THE
OWNER’S MANUAL**)
Inspect for rips, tears. XX
REAR WHEELS (PROCEDURE 9 OF THE OWNER’S
MANUAL**)
No excessive side movement or binding when raised and turned. XX
FRONT WHEELS (PROCEDURE 9 OF THE OWNER’S
MANUAL**)
Inspect wheel/fork assembly for proper tension by spinning
wheel, wheel should come to a gradual stop. XX
Loosen/tighten locknut if wheel wobbles noticeably or binds to a stop. XX
Wheel bearings are clean and free of moisture. XX
CAUTION: As with any vehicle, the wheels and tires should be
checked periodically for cracks and wear and should be replaced.
TILLER (PROCEDURE 8 OF THE OWNER’S MANUAL**)
Ensure that tiller adjustment handle engages and
disengages properly and securely (PROCEDURE 3 OF
THE OWNER’S MANUAL**). XX
Scooter stops completely when throttle is released
(Does not continue to roll as if throttle is activated). X X
SEAT (PROCEDURE 5 OF THE OWNER’S MANUAL**)
Inspect seat swivel for release and engagement. XX
Seat locks into the determined swivel positions. XX
TIRES (PROCEDURE 9 OF THE OWNER’S MANUAL**)
Inspect for flat spots and wear. XX
CAUTION: As with any vehicle, the wheels and tires should be
checked periodically for cracks and wear and should be replaced.
CLEANING
Clean upholstery and armrests. X
Clean molded frame. X
FRONT AND REAR SHOCKS - PANTHER MX-4 ONLY
Bolts are tight. XX
HEADLIGHTS (where applicable)
Inspect headlight bulbs for proper operation.
XX
**NOTE: Refer to the Owner’s Manual, part number 1090132.
To Next Page
Loading...
Need help?
General