Jeep UNIVERSAL CJ-2A - I-79. Service Diagnosis-Continued

'Jeep' UNIVERSAL and 'Jeep' DISPATCHER
I-79. SERVICE DIAGNOSIS- Con tinu ed
SYMPTOMS
Di st ri buto r:
Hard Starting -
Distributor Points Burned or Pitted . .... . . . . .
Breaker Arm Stuck on Pivot Pin .... . .. .. . .. .
Breaker Arm Spring Weak .. .... .. ......... .
Points Improperly Adjus te d ... .. ..... .... .. .
Spark Plug Points Improperly Set . ..... . . ... .
Spark Plug Wir e Terminals in Distribu tor
Cap Corroded ...... . . ....... . .. ...... . . .
Loose Terminals ... . ... .... .... . .... ... .. . .
Loose or Dirty Terminals on Gr o und Strap -
Engine to Frame .. .. .. ... ... . ....... .... .
Condenser Faul ty ......... .. ...... . . . . . . . . .
Improper Ignition Timing .... .. ... .. ... .. . . .
Li gh ts:
Burn Dim -
Loose or D irty T erminals .... . .. ...... .. . .. .
L
eak in Wires .............. . . . . .... . .. . . . .
Poor Switch Cont act ... .... . . .. .. . . . . .. . . . .
Poor Ground Connection .. . .............. . . .
Aim -q eadla fY' :-' Beams ... .. ... .... . ........ .
H orn Fa il s to Sound:
PROBABLE REMEDY
Clean Points or Replace (Adjust)
Clean and Lubricate
Replace
Adjust . 020 '
Adjust .030"
Clean
Check Circui t
Clean and Ti ghten
Repla ce
Set Timing
Clean and Ti gh ten
Check Entire Circuit for Broken Insul atio n
Install New Switch
Clean an d Ti g hten
Use A im ing Chart
I
Br oken or Loose Electrical r.onne ct ion... . .... .. Check Wirin g and C onnect ions at Horn Button and
Battery - Clean and Tight en
Ba ttery Low or D ead ...................... . .. Ch eck Battery
C ontact P oints B urned or Broken Off. ... . .. ... . Replace Part s Necess a ry
Horn Sound s Un sa ti sfa ctor y Ton e:
Poor Electric al Conn e ction .. ... ..... .. .... . . . .
Bat te ry Low .... .... .. ..... .. .... .. ...... . . .
Loose Cov er and Bracket Screws .. ........ .... .
Voltage at Horn too High or too Low . . .. . .. ... .
Check Connections at Horn, Horn Bu tton, Battery
Check with Hydrom ete r
Tigh te n Br acket B o lts at H nrn
Check with Vo ltmet er
151