Jeep UNIVERSAL CJ-2A - Air Cleaner

'Jeep' UNIVERSAL and 'Jeep' DISPATCHER
LUBRICA.TION SPECIFICA.TIONS
MODELS C
J -3B, C J -5 A.ND C J -6
FIG. 15-LUBRICATION CHART-MODELS CJ-3B, CJ-5, CJ-6
B
11096
i
!
QUANTITY
LUBRICANT
CHART ITEM TO BE
I
NO.
LUBRICATED
I
FREQUENCY TYPE
I
GRADE
I
u.s. Imperial
Metric
1000 miles-1.600 km.
Summer
I
Winter
----
I. Chassis Bearings . ........
Each 1000 miles As required Chassis Lubricant
No.1 No. 0
2.
Spring Shackle Bushings ...
{With lube fittings: Each IOOO miles
I
As required Chassis Lubricant
No.1 No. 0-
I
Spring PivotBoltBushings
Without lube fittings: No lubrication
I
Universal Joints
Each 1000 miles
I
Universal Joint
No.1
No. a
I
As required
Lubricantt
3
Propeller Shaft
.......
{Check each 1000 miles
Universal Joint
4. Front Axle Shaft .......
Change each 12.000 miles (19.200 Km.J
As required
Lubricantt
No.I
No. 0
5. Steering Gear Housing . ... Check each 1000 miles
As required
MIL-L-2105B SAE 80
SAE 80
6
Rear Wheelo ............. Sparingly each 1000 miles
As required
\''heel Bearing
No.2
No.2
.... ubricantt
1. Front Wheels .....
······
Disassemble to lubricate each
I
As required
Wheel Bearing
No.2
No.2
I
6000 miles (9.600 km.J
Lubricantt
I
8. 3-SpeedTransmission and
{Check each 1000 miles 67!! pts. 5 72 pts. 3 ltrs.
GL4
SAE90
SAE 80
Transfer Case . .........
Change each 10,000 miles
0
4-Speed. Transmission I Check each 1000 miles 6')4 pts. 5')4 pts.
3,2 ltrs.
GL4
SAE 90 SAE 80
Transfer Case . ...........
t Change each 10,000 miles 3~ pts. 3 pts. 1,7 ltrs.
GL4
SAE 90 SAE 80
Differentials
'1.
Front ................. {Check each 1000 miles
I
2 7li pts. 2 pts. 1,2
ltrs.
MIL-L-210SB•
SAE80
SAE 80
lu. Rear .................. Change each 10,000 miles
2 72 pts. 2 pts. 1,2
ltrs.
MIL-L-2105B*
SAE 80 SAE 80
Speedometer Cable ....... Disassemble to lubricate each
As required
Graphite Grease
Light
12,000 miles (19.200 km.l
Distributor
Oiler ..................
Each 1000 miles
Several drops
Engine Oil
Same as engine
Wick .................
Each 1000 miles
One drop
Engine Oil
Same as engine
Pivot ................. Each 1000 miles
One drop
Engine Oil
Cam ..................
Each 1000 mileo
-:.
2 c. c.
Cam Lubricant
Same as engine
I
I
Air Cleaner . .............
Generator ...............
Engine ..................
0 0
Not lower than 32 F. (0 C.)
use SAE 30 or
10W-30
Each 2000 miles
Each 1000 miles
Change each 2000 miles
0
-
0
Not lower than 10 F.~ 12 C)
use SAE 20, 20W.
lOW-30, or lOW-20
1 )4 pts.
14 qts.**
*For Powr-Lok differential use only Willys Powr-Lok Differential Oil, Part No. 94557 .
..,When oil filter ia changed at the same time, add one quart jone ltr .j
1 pt.
591,4cm'
2-4 drops
3 72 qts. 3,8 ltrs.
0
0
As low as 10 F. ( 23 C.)
use SAE lOW,
lOW-30, or !OW-20
0
4-Speed transmission and transfer case (optional on CJ-5 and Cj-6) require separate lubrication of each unit.
tSodium base lubricants recommen&:~d; do not mix sodium base and lithium base lubricants.
Engine Oil
Engine Oil
Same as engine
Same as engine
0
0
Below 10 F. ( 23 C.)
use SAE SW or
SW-20
11