Jeep UNIVERSAL CJ-2A - N-23. Service Diagnosis

'Jeep' UNIVERSAL and 'Jeep' DISPATCHER
N
N -23. SERVICE DiaGNOSIS
SYMPTOMS PROBABLE REMEDY
Axle Noisy on Pull and Coast
Excessive Back Lash Bevel G ear and Pinion .. . . . . . . . . .. . . . . . . . . .
End Play Pinion Shaft . . . . . .. ... . .. . . .. . . . .. . . .. . .. . . . . .. . . . . . . . . .
W
orn Pinion Shaft B earing . . . . ... . . ... . .. . .. .. . . . ... . . . .. . . . . .... .
Pin i on Set too Deep in Bevel G ear . . . .. .. . .. . .. . . . . . . . . . . . . . .. .. . . .
Pinion and Bevel Gear too Tight .. . .. .. .. . ... . ....... . . . . . . ... . . . . .
Wrong Lubricant Being Used (Powr - Lok Differential) . . . . . . . ... .. .. . .
Axle Noisy on Pull
Pinion and Bevel Gear Improperly Adj usted .. .... .. . .. . . . . . . . . .. . . . .
Adjus t
Adjust
Replace
Adjust
Adjust
See "Differential
Chatter" under
"Trouble Shooting
Powr - Lok" in this
Section.
Adjust
Pinion Bearings Rough .. . . . ... . ... . . . . . . .. . . . ·. . . . . . . . . . . . . . . . . . . . Replace
Pinion B earings Loos e. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Adjust
Axle Noisy on Coast
Excessive Back Lash in Bevel Gear and Pinion .. .... . . . .. . . . . . . . .. . .
End Play in Pinion Shaft . . . . .. . . . . .. . .. . . . . . . . . . .... . .. . . . . .. . . . .
I
mproper Tooth Contact . . .. . .. .. . . . .. . . . . . .. . . . . .. . . . .. . . . . . . . . . .
Rough Bearings .. . . . . .... . .. . . . . . . . .... . .. . . . . . . .. . .. . ... . .. . . . . .
Bac k L as h
Worn Differentia l Pinion Gear Washers .. . . . . . . . .. . . . .. .. . . . . . . . . . . .
Adjust
Adjust
Adjust
Replac e
Replace
Excessive Back Lash in Bevel Gear and Pinion. . . . . . . . . . . . . . . . . . . . . Adjus t
Worn Un iv ersal Joints. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Repla ce
Vehicle Vibration ( Model DJ-3A ) ... . . . . . .. . , . . . . . . . . . . . . . . . . . . . . . . Se e "Trouble
Shooting " on pre -
ceding page .
211