Jungheinrich DFG 670 - Customer Service

215
11.14 EN
11.2 Customer Service
11.2.1 Standard Equipment
Brakes W A B C
1 Test brakes. t
2 Check the brake lining on the parking brake. t
3 Check connections and lines for leaks. t
Electrical System W A B C
1
Test warning and safety devices in accordance with operating
instructions.
t
2 Test displays and controls. t
3 Test the main switch / battery isolator. t
4 Test Emergency Disconnect switch. t
5 Check contactors and/or relays. t
6 Check fuse ratings. t
7
Check electrical wiring for damage (insulation damage,
connections). Make sure wire connections are secure.
t
Power supply WABC
1 Final adjustments to the LPG system. t
2
Check battery cable connections are secure, grease terminals if
necessary.
t
3 Check battery and battery components. t
4 Check battery voltage. t
5
Note: check the exhaust levels every six months and adjust if
necessary. Observe other national guidelines and regulations.
6
Note: The LPG system must only be inspected by LPG system
experts.
7 Test the LPG system and check for leaks and damage. t
8 Replace the LPG filter. t
Travel W A B C
1 Replace transmission oil filter. t
2
Check transmission oil level or grease filling of the transmission and
top up if necessary.
t
3 Replace the axle return filter. t
4 Test exhaust system and check for leaks and damage. t
5 Test anti-freeze, top up if necessary. t
6 Replace radiator fluid and anti-freeze. t
7 Check cooling system for leaks. t
8 Check coolant level and top up if necessary. t
9 Test hydraulic fans and check for leaks. t