KitchenAid 720-0733D - Trouble Shooting; Assistance; Accessories

TROUBLE SHOOTING
 Is the 20 lb LP gas fuel tank valve turned off?
Turn the 20 lb LP gas fuel tank on
 Is there excessive fat in the food being grilled?
Keep flame on low or turn one burner off.
Keep the hood up when grilling to avoid excessive flare-ups.
Grill will not light
Excessive flare-ups
Turn
the
20
lb
LP
gas
fuel
tank
on
.
 Is the grill properly connected to the gas supply?
Contact a trained repair specialist or see Installation Instructions.
 Is there gas in the 20 lb LP gas fuel tank?
Check the gas level.
 Is the igniter working?
Check that the igniter batter is properl installed or check to
Move food to the warming rack until flames subside.
To avoid damage to the grill, do not spray water on gas flames.
LP Gas:
For outdoor grills using a 20lb LP gas fuel tank, slowly open the
tank valve.
Low heat
Check
that
the
igniter
batter
y
is
properl
y
installed
or
check
to
see if the battery needs to be replaced. See the “Replacing
the Igniter Battery” section.
Check to see if the grill will match-light. See “Manually
Lighting the Grill and side burner” in the “Outdoor
Grill Use” section.
Check for loose wire connections to the igniter or electrodes.
NOTE: If flow limiting device activates, your grill may not light. If
your grill does light, the flames will be low and will not heat
properly.
1. Turn tank valve and all control knobs off and wait 30 seconds.
2. After shutting off the tank, very slowly open the tank valve and
wait 5 seconds before lighting.
3. Light the burners one at a time. See “Lighting the Grill and side
burner” section.
Natural Gas:
Check to see if debris is blocking the electrodes.
If a spark occurs anywhere but the igniter tip, replace the
igniter.
 Is the gas supply fully turned on?
Check that the 20 lb LP gas fuel tank valve is fully open.
Burner flame will not stay lit
Natural
Gas:
Gas pressure is affected by size and length of the gas line from
the house to the grill. Contact a qualified gas technician to
provide the Natural gas supply to the selected grill location in
accordance with the National Fuel Gas Code ANSI Z223.1/
NFPA54 - latest edition and local codes.
ASSISTANCE
 Is the gas supply in the 20 lb LP fuel gas tank low?
Check the gas level.
 Is the burner properly installed and in good condition?
Check that the burner is installed properly. Check for defects in
the burner.
Flame is nois
y,
low or erratic
Before calling for assistance, please check “Troubleshooting.” If
you still need help, follow the instructions below.
When calling, please know the purchase date and the complete
model and serial number of your appliance. This information will
help us to better respond to your request.
ASSISTANCE
 Is the gas supply fully turned on?
Check that the 20 lb LP gas fuel tank valve is fully open.
 Is the gas supply in the 20 lb LP fuel gas tank low?
Check the gas level.
 Does only one burner appear low?
Ch k dl thb tifl d dit S
y,
If you need replacement parts
If you have questions or need to order replacement parts,
contact Customer Service Center at 1-877-373-2301 .
Please direct all correspondence to:
Nexgrill Industries, Inc.
14050 Laurelwood Place, Chino, CA 91710
Please include a daytime phone number in your
Ch
ec
k
an
d
c
l
ean
th
e
b
urner por
t
s
if
c
l
ogge
d
or
di
r
t
y.
S
ee
“General Cleaning” section.
 Is the gas supply hose bent or kinked?
Straighten the gas supply hose.
 Is the flame noisy or lifting away from the burner?
Burner may be getting too much air. Check the air shutter
adjustment, see “Check and Adjust Burners” section.
Please
include
a
daytime
phone
number
in
your
correspondence.
Accessories
Natural Gas Conversion Kit
Order Part Number 710-0003
 Is the burner flame mostly yellow or orange?
Grill may be in an area that is too windy, or not receiving
enough air. Check the burner air inlets for obstructions.
Check the air shutter adjustment, see “Check and Adjust the
Burners” section.
Rotisserie Kit
Order Part Number 790-0007A
31