Home
Koden
Marine Radar
MDC-5000 Series
Koden MDC-5000 Series Service Manual
186 pages
Manual
Specs
Ask a question
To Next Page
To Next Page
Loading...
2
Table of Contents
Default Chapter
4
Important Notice
4
For Your Safe Operation
5
Break in Procedure of Stored Radar
9
Disposal of Used Cells and this Radar
10
Table of Contents
11
Chapter 1 Fault Diagnosis
15
About Alarms
15
Malfunction Detection Step
16
Malfunction Diagnosis Flowchart
17
Initial Malfunction Diagnosis 1
17
Initial Malfunction Diagnosis 2
18
Other Faults (Display Unit)
19
Abnormal Display
20
No Response from the Antenna Scanner Unit
21
Sensitivity Failure
22
No Display of Ship's Bearing, Speed and Latitude/Longitude
23
Operation Unit Abnormality
24
Antenna Scanner Unit Abnormality
25
Synchronization of Screen Abnormality
26
High Voltage Abnormality
26
Pulse Length Control Failure
27
Rotary Abnormality
28
Heading Line and Azimuth Abnormality
29
TT (ATA) Abnormality
30
Chart Display Abnormality
31
No Display of AIS
32
Other Faults (Antenna Scanner Unit)
34
Failure Criterion of Microwave Components
38
Magnetron
38
Front-End Module
38
Limiter
38
Chapter 2 MAINTENANCE MENU
39
Bite
39
Panel Test
39
Diagnose Tt
39
Diagnose Ais
40
Serial Monitor
41
Ant Monitor
42
Sd Card
42
Echo
43
Gain Offset
43
Sea Curve
43
Chapter 3 How to Exchange Components
45
Display Unit
45
Replacement of Fuse
45
Dismantling of Bracket and Rear Case (MRD-108 / MRD-108P)
46
Dismantling of Bracket and Rear Case (MRD-109)
47
Dismantling of Bracket and Rear Case (MRD-111)
48
Exchange of Logic PCB (MRD-108/108P/109/111/MRM-108/108P/110)
49
Exchange of Power Supply PCB (MRD-108/108P/109/111, MRM-108/108P/110)
51
Exchange of LCD Unit (MRD-108/108P)
53
Exchange of LCD Unit (MRD-109)
55
Exchange of LCD Unit (MRD-111)
57
Exchange of Backlight Power PCB (MRD-108/108P)
60
Exchange of Rear Card Connector PCB (MRD-108/108P/MRM-108/108P/110)
61
Exchange of Connector PCB (MRD-109)
62
Exchange of Connector PCB (MRD-111)
63
Operation Unit
64
Exchange of Panel PCB (MRO-108/108P)
64
Exchange of Panel PCB (MRD-111)
67
Exchange of Track Ball (MRO-108/108P)
68
Exchange of Sillcon Key (MRD-111)
70
Antenna Scanner Unit
71
Dismantling of Antenna and Antenna Cover
71
Exchange of Azimuth Pulse Unit and Drive Unit Motor (RB806 / 807 / 717A / 718A / 719A)
73
Exchange of V Ring
75
Exchange of Modulator PCB
80
Exchange of Fan (RB809 Only)
83
Exchange of Fan (RB719A Only)
84
Exchange of Magnetron (RB806)
85
Exchange of Magnetron (RB807,RB808/808P)
87
Exchange of Magnetron (RB809/809P)
89
Exchange of Magnetron (RB717A, RB718A)
91
Exchange of Magnetron (RB719A)
93
Exchange of Transformer (RB809/809P)
95
Exchange of Transformer (RB717A, RB718A)
97
Exchange of Transformer (RB719A)
98
Exchange of MIC (RB806)
100
Exchange of if MODULE (RB807/808/808P/809/809P)
101
Exchange of if PCB, MIC and Limiter Device
102
Chapter 4 Spare Parts and Circuit Diagram
109
Spare Parts
109
Circuit Diagram
142
Interconnection Diagam of 4Kw Scanner Unit (RB806)
143
Interconnection Diagam of 4 Kw Scanner Unit (RB716A)
144
Interconnection Diagam of 6 Kw Scanner Unit (RB807)
145
Interconnection Diagam of 6 Kw/12 Kw Scanner Unit (RB717A/718A)
146
Interconnection Diagam of 12 Kw Scanner Unit (RB808)
147
Interconnection Diagam of 12 Kw Scanner Unit (RB808P)
148
Interconnection Diagam of 25 Kw Scanner Unit (RB809)
149
Interconnection Diagam of 25 Kw Scanner Unit (RB809P)
150
Interconnection Diagram of 25 Kw Scanner Unit (RB719A)
151
Inter Connection Diagram MRD-108/MRD-108P
152
Inter Connection Diagram MRM-108/MRM-108P
153
Inter Connection Diagram MRD-111
154
Inter Connection Diagram MRD-109
155
Inter Connection Diagram MRM-110
156
Circuit Diagram Power Supply PCB
157
Circuit Diagram of BACK LIGHT POWER PCB
159
Circuit Diagram of PANEL BOARD (E63-900*)
160
Circuit Diagram of PANEL BOARD (E68-900*)
161
Circuit Diagram of PANEL BOARD (E73-900*)
162
Circuit Diagram of CONNECTOR PCB (E63-911*)
163
Circuit Diagram of CONNECTOR PCB (E68-910*)
164
Annex
165
Clean up the Trackball
165
Interface
167
Relation between Functions and Input Signal
167
Kind of Input/Output Ports
168
Setup Interface
169
Confirmation of Input Signal
175
Connection of Gyro Convertor S2N
176
Gyro/Log Interface: Connection of ADPC-101 Unit (Non-IMO
178
Connection of LOG Pulse NMEA Converter L1N (200 Pulse/Nautical Mile Only
180
Connection of AIS
181
System Program
183
Version Confirmation
183
How to Update the System Program
184
Other manuals for Koden MDC-5000 Series
Manual
2 pages
Quick Reference
28 pages
Need help?
Do you have a question about the Koden MDC-5000 Series and is the answer not in the manual?
Ask a question
Koden MDC-5000 Series Specifications
General
Display Type
Color LCD
Power Supply
24 V DC
Transmitter Power
4 kW
Frequency
9410 MHz
Antenna Rotation Speed
24/48 RPM
Display Size
12.1 inches
Related product manuals
Koden MDC-5004
192 pages
Koden MDC-5204
182 pages
Koden MDC-5200 SERIES
182 pages
Koden MDC-7025
160 pages
Koden MDC-2240
129 pages
Koden MDC-7060
234 pages
Koden MDC-2540
129 pages
Koden MDC-7912P
152 pages
Koden MDC-900 Series
83 pages
Koden MDC-2000 series
82 pages
Koden MDC-7000 Series
186 pages
Koden MDC-2200 series
2 pages