KTM 250 EXC 2016 - User Manual

Other manuals for KTM 250 EXC 2016

Questions and Answers

T
terrigarrettAug 9, 2025
Why does my KTM Motorcycle engine overheat?
- R
  Ricardo HollowayAug 9, 2025
  Your KTM Motorcycle engine may overheat due to several reasons. It could be due to too little coolant in the cooling system, which means you should check the cooling system for leakage and the coolant level. Insufficient airflow can also cause overheating, so switch off the engine when stationary. Very dirty radiator fins, foam formation in the cooling system (in this case, drain and refill the coolant), a damaged cylinder head or cylinder head gasket (check them), a bent radiator hose (replace it), or an incorrect ignition point due to a loose stator (adjust the ignition on all 125 models) can also be the cause.
P
Paul McbrideAug 15, 2025
How to fix KTM Motorcycle engine stalling or popping into the carburetor?
- M
  Matthew BatesAug 15, 2025
  If your KTM Motorcycle engine stalls or pops into the carburetor, it might be taking in bad air. In this case, check the intake flange and carburetor for tightness. Also, the connector or ignition coil may be loose or oxidized; if so, clean the connector and treat it with contact spray.
J
Jason ReyesAug 21, 2025
What to do if my KTM 250 EXC 2016 Motorcycle emits white smoke?
- J
  Janet BoydAug 21, 2025
  If you observe white smoke emission (steam in exhaust gas) from your KTM Motorcycle, it could be due to a damaged cylinder head or cylinder head gasket. Inspect the cylinder head and cylinder head gasket.
H
hhopkinsAug 27, 2025
Why is gear oil coming out of the vent hose on my KTM Motorcycle?
- A
  agrahamAug 27, 2025
  If gear oil exits at the vent hose of your KTM Motorcycle, it's likely because too much gear oil was added. Check the gear oil level.
M
Melissa Jones DVMSep 2, 2025
How to troubleshoot water in the gear oil of my KTM 250 EXC 2016?
- U
  ubaxterSep 2, 2025
  If there's water in the gear oil of your KTM Motorcycle, a damaged shaft seal ring or water pump could be the cause. Check the shaft seal ring and water pump.

KTM 250 EXC 2016 Specifications

General

Displacement	249 cm³
Bore x Stroke	66.4 mm x 72 mm
Transmission	6-speed
Front Brake	Disc brake
Rear Brake	Disc brake
Cooling	Liquid cooled
Seat Height	960 mm
Ground Clearance	380 mm
Engine Type	2-stroke
Front Suspension	WP USD 48 mm
Rear Suspension	WP shock absorber
Fuel Tank Capacity	9.5 liters
Fuel System	Carburetor
Frame	Chromoly steel