Page | 32 Proofer Operators Manual 1-2022 (English)
Copyright 2022 LBC Bakery Equipment Inc. Tulalip WA
Limited Warranty
LBC Bakery Equipment (“LBC Equipment”) has been skillfully manufactured, carefully inspected and packaged to meet rigid
standards of excellence. LBC Bakery Equipment, Inc. (LBC) warrants products produced and sold by LBC and its duly
authorized agents, against defects in materials and workmanship within the following limitations:
What is Provided:
• Limited replacement parts as specified below, including
standard ground shipping from LBC or service parts center
when required.
• Limited labor for repair as specified below, including
authorized service agent’s transportation, portal to portal,
up to one hundred (100) miles round trip and two (2) hours
travel time.
• LBC, or an authorized service representative, will repair at
LBC’s sole discretion, any new LBC equipment, according to
the limits and exclusions listed in this limited warranty.
Coverage Period:
Extending from the date of shipment from LBC or its duly
authorized dealer/distributor for the specified period.
• LBC Equipment (Rack Ovens, Proofers, Retarder/proofers,
Retarders, Rotisseries, Deck Ovens, Conveyor Ovens) shall
be warranted for a period of one (1) year, limited parts and
labor.
• Heat Exchanger Tubes on oven models LRO-1G5 and LRO-
2G5 for a period of ten (10) years, limited parts and labor.
• Replacement Parts purchased from LBC or Authorized
supplier shall be warranted for a period of ninety (90) days
after installation by an authorized LBC service agent.
Conditions:
• Covered equipment must have been properly installed and
according to the requirements of the installation manual and
all applicable local codes.
• An Equipment Start-Up must have been performed by an
authorized LBC servicer and the completed start-up form
returned to LBC.
• The equipment shall not have been abused, misused or
neglected or used for purposes other than intended by LBC.
• Water connected to the appliance shall have been in
compliance with the following requirements:
o Cold water, 40 to 80 PSI (Hot water to Rotisseries)
o pH between 7 and 7.5
o Conductivity less than 1/500,000 Ω per inch
o Total dissolved solids less than 100 ppm
o Hardness from 6.3 to 8.8 grains per gallon
o Maximum Salinity and Ion content:
Chlorides: < 30 ppm
Sulfates: < 40 ppm
Iron: < 0.1 ppm
Copper: < 0.05 ppm
Manganese: < 0.05 ppm
It is the responsibility of the purchaser to install and maintain the
water supply to the appliance. Failure to provide satisfactory
water quality to the appliance in accordance with the operating
manual requirements can cause damage to internal components
and will VOID the warranty.
• Conditions (cont):
• All repair work is to be performed by an LBC authorized service
agent.
• Equipment must be at the operating location of the original
purchaser/user and shall not have been resold or reclaimed by
another party.
• LBC equipment is for commercial use only. If sold as a
component of another (OEM) manufacturer’s equipment, or if
used as a consumer product, such equipment is sold AS IS and
without any warranty.
• Conditions of sale of the equipment shall have been met in full.
• The request for repair shall be made within the limited period of
the warranty.
Failure to meet the above conditions will void this warranty
Exclusions:
This warranty does not cover the following:
• Routine general maintenance, or periodic adjustment
• Consumable items including but not limited to, light bulbs,
glass, door gaskets, rack bumpers etc.
• Thermostat calibration after the first 30 days of use
• Air and gas burner adjustments
• Fuse replacement
• Cleaning and adjusting burners, pilot burners or heat
exchangers
• Rack oven shutter adjustments
• Repairs, adjustments and corrections in the refrigeration portion
of retarder/proofers resulting from the improper installation
• Retightening of screws and fasteners
• Failures caused by erratic or inadequate electrical, water,
ventilation or gas service
• Unauthorized repairs
• Premature rusting, corrosion, or mineral build up caused by
incoming water
• Attached water treatment systems
• Expedited freight on replacement parts other than standard
ground shipments
• Ordinary wear and tear
• Use of the equipment for purposes other than those intended
including non-commercial use such as residential or domestic
• Appliances installed outside the contiguous U.S., including
Alaska and Hawaii, and Canada
• Incidental costs, charges, loss of business and damages as
incurred by the user or others as a result of the use or failure of
the equipment
• Work and workmanship of the authorized service agent or
others in the repair of the equipment
• Other failures that are beyond the reasonable scope of this
warranty
• Damages caused during shipment are to be reported to the
carrier, are not covered under this warranty, and are the sole
responsibility of the purchaser/user
• Natural disaster
This warranty is exclusive and in lieu of all other warranties, expressed or implied, including expressed or implied warranties of merchantability or
fitness for a particular purpose, each of which is hereby expressly disclaimed. The remedies described herein are exclusive and in no event shall LBC
be liable for special, consequential or incidental damages for the breach or delay in the performance of this warranty.
To Previous Page
Loading...