ating under heavy load or in hot weather.
imade sure that the gasket is in the right
Refit the drain plug and fully tighten it having
Close the cap again and clean up any
“MAX” notch on the dipstick.
Fill up with fresh oil.
oil and unscrew the drain plug.
unscrew the cap with dipstick.
SAFETY RECOMMENDATIONS
Remove the spark plug
cap and read instructions before carrying
out any cleaning, repair or maintenance
operation. Wear proper clothing and work-
ing gloves whenever your hands are at risk.
Do not perform maintenance or repair oper-
ations without the necessary tools and
technical knowledge.
Never get rid of used oil, fuel
or other pollutants in unauthorised places.
MAINTENANCE SCHEDULE
Follow the hourly or calendar – whichever occur
first – maintenance schedule shown in the fol-
lowing table.
1)
Change oil every 25 hours if the engine is oper-
2)
Clean air cleaner more frequently if the
machine is operating in dusty areas.
3)
To be carried out by a specialized Centre.
6.2
IMPORTANT
!
WARNING!
6.1
6. MAINTENANCE
CHANGE OIL
See the specific chapter (8.1) for the oil to be
used.
Drain oil while the engine
is warm, being careful not to touch the hot
engine nor the drained oil.
a) Place the machine on a flat surface.
b) Clean the area around the filler cap and
c) Provide a suitable container for collecting the
d)
position.
e)
f) Check that the oil level has reached the
g)
traces of oil that was possibly spilt.
liter.
NOTE
!
WARNING!
6.3
6
EN
Check oil level - ✔ --
Change oil
1)
✔ --✔
- ✔ --
Air filter cleaning
2)
- ✔ --
Air filter replacement
2)
--✔ -
Check spark plug
--✔ -
Replace spark plug
---✔
Fuel filter check
3)
---✔
Operation
After First 5 hours
Every 5 hours or
daily
Every 50 hours or
every season
Every 100 hours
Clean silencer and engine
and check
The oil capacity is about 1.6
!
WARNING!
·The length of time that gasoline can be
left in your fuel tank and carburetor
without causing functional problems will
vary with such factors as gasoline blend,
your storage temperatures, and whether
the fuel tank is partially or completely
filled. The air in a partially filled fuel tank
promotes fuel deterioration. Very warm
storage temperatures accelerate fuel
deterioration. Gasoline will oxidi
ze and
deteriorate in storage. Deteriorated
gasoline will cause hard starting, and it
leaves gum deposits that clog the fuel
system. As a result, If the engine is not
used for more than one month, the fuel oil
shall be drained thoroughly to prevent
from deterioration of the fuel in fuel
system and carburetor.
The failures of fuel system or engine
performance arising from
improper storage are beyond
the scope of
the warranty.
·
To Next Page
Loading...
Need help?
General
