Lopi Evergreen User Manual

Evergreen
Wood Stove
Owner's Manual
 Freestanding Stove
 Hearth-Stove Approved
Save these instructions
for future reference
SAFETY NOTICE:
If this appliance is not properly installed, a house fire
may result. For your safety, follow the installation
directions. Contact local building or fire officials about
restrictions and installation inspection requirements
in your area.
Dragon Wholesaling Pty. Ltd.
Unit 4, 16 Lexington Drive
Bella Vista NSW
Australia 2153
 Copyright 2016,
Travis Industries, Inc.
$10.00
100-01438
4160303
Tested by:
HRL Technology
Tramway Road, Morwell 3840
Victoria
Tested to: AS/NZS 4012/4013: 2014
Report Number: HCMG-016-006

Lopi Evergreen Specifications

General

Type	Wood Stove
Maximum Burn Time	Up to 10 hours
Firebox Size	2.2 Cubic Feet
Maximum Log Length	20 inches
EPA Certified	Yes
Blower Included	Optional
Material	Steel
Efficiency	76.9% (HHV)

Summary

Safety Notice

Introduction

Important Information

Record model and serial number for service.

Safety Precautions

Features & Specifications

Installation Options

Details on freestanding or hearth mounting options.

Features

Overview of the stove's design and capabilities.

Heating Specifications

Information on heating capacity and BTU output.

Dimensions

Diagrams and measurements of the stove.

Emissions

Appliance emission factors and efficiency ratings.

Stove Installation

SAFETY NOTICE

Critical warning about proper installation and contacting officials.

Planning the Installation

Guidance on placement and consulting local authorities.

Preparation for Installation

Checks for baffles, damage, and firebricks before setup.

Packing List

Items included with the stove for installation.

Floor Protection Requirements

Specifies non-combustible material and thermal resistance.

Stove Placement Requirements

Details clearances to combustibles and air source needs.

Clearances

Table listing minimum clearance distances to walls and hearths.

Chimney Connector Requirements

Guidelines for connecting the stove to the chimney.

Chimney Requirements

Specifies types and standards for chimney systems.

Drafting Performance

Factors affecting appliance draft and efficiency.

Chimney Termination Requirements

Rules for chimney cap and exit height above the roof.

Outside Air Requirements

Specifications for connecting an external air source.

Standard Ceiling with a Factory-Built Chimney

Diagram and notes for standard installations.

Cathedral Ceiling with a Factory-Built Chimney

Diagram and notes for cathedral ceiling installations.

Exterior Factory-Built Chimney

Installation details for external chimney systems.

Wall Penetrations Under 1.8796 meters (74")

Method for passing chimney through walls.

Hearth Stove Installation

Specific requirements for installing stove on a hearth.

Interior or Exterior Masonry Chimney

Guidelines for venting through masonry chimneys.

Operating Your Appliance

Safety Notice

Reinforces warnings about installation and contacting officials.

Before Your First Fire

Instructions for verifying installation and keeping flammables away.

Curing the Paint

Process for heating the stove to cure the paint finish.

Carbon Monoxide (CO) Emissions

Information on CO, efficient burning, and dry wood.

Over-Firing the Stove

Warnings and indicators of excessive heat that can damage the stove.

Opening the Door

Procedure to safely open the door during operation.

Bypass Operation

How the bypass controls smoke flow and draft.

Starting a Fire

Step-by-step guide for safely igniting the stove.

Adjusting the Burn Rate

How to use the air control slider for different burn rates.

Understanding Your Heater's Combustion System

Explanation of primary and secondary combustion.

Ash Removal

Procedure for safely removing ashes from the stove and ash pan.

Ash Pan

Warnings and instructions for operating with the ash pan.

Ashpan Removal – Pedestal Version

Steps to remove the ashpan from a pedestal model.

Ashpan Removal – Stove Version

Steps to remove the ashpan from the standard stove.

Re-Loading the Stove

Instructions to minimize smoke spillage when adding wood.

Overnight Burn

Steps to achieve extended burn times up to 10 hours.

Normal Operating Sounds

Description of expected creaks, clicks, and blower noise.

Hints for Burning

Tips for efficient operation and fuel selection.

Selecting Wood

Guidance on choosing and preparing wood for burning.

Why Dry Wood is Key

Explanation of the importance of dry wood for performance.

Wood Cutting and Storage

Recommendations for preparing and storing firewood.

Do Not Burn List

Materials that should never be burned in the stove.

Troubleshooting

Common problems and their possible causes and solutions.

Maintaining Your Appliance

Daily Maintenance (while stove is in use)

Cleaning the glass and routine checks.

Monthly Maintenance (while appliance is in use)

Inspecting door seals and gaskets.

Door and Glass Inspection

Checking the door gasket for an air-tight seal.

Door Adjustment

How to adjust the door latch for a proper seal.

Creosote - Formation and Need for Removal

Understanding creosote and chimney fire risks.

Yearly Maintenance

Tasks for annual upkeep of the appliance.

Door Parts

List of components for the stove door assembly.

Replacing the Glass

Instructions for safely replacing the stove's glass panel.

Replacing the Door Gasket

Procedure for installing a new door gasket.

Replacing the Door Handle

Guidance on replacing the door handle assembly.

Removing the Door

Steps to detach the door from the stove for maintenance.

Firebox Parts

List of components within the stove's firebox.

Baffle Removal & Replacement

Instructions for servicing the firebox baffles.

Air Tube Removal & Replacement

Steps to remove and replace air tubes in the firebox.

Firebrick Removal & Replacement

Instructions for replacing damaged firebricks.

Limited 7 Year Warranty

Years 1 THROUGH 2- COVERAGE: PARTS & LABOR

Warranty coverage details for the first two years.

Years 3 THROUGH 5 - COVERAGE: PARTS & LABOR

Warranty coverage details for years 3-5.

Years 6 THROUGH 7 - COVERAGE: PARTS

Warranty coverage details for years 6-7.

CONDITIONS & EXCLUSIONS

Terms and limitations of the appliance warranty.

IF WARRANTY SERVICE IS NEEDED:

Procedure for reporting and obtaining warranty service.

Listing Information

Listing Label

Information regarding the appliance's safety and performance certifications.

Optional Equipment

Optional Rear Blower (Part # 99000143A)

Information on the optional rear blower accessory.

GreenStart™Woodstove Igniter (Part # 94400951A)

Information on the optional igniter accessory.

GreenStart Igniter Installation Addendum

Specific installation notes for the igniter.