LS tractor MT225E

To Next Page

To Previous Page

4 -34

③ Attaching points for Front-end loader

 When attaching the front-end loader, refer to the drawings as below.

Main Page

Table of Contents5
General Notices for Safety11
Note to the Owner - General Information11
Before Using the Tractor13
Manual Scope and Required Training Level15
Metric and Imperial Units Abbreviations17
Product Identification Number (PIN)19
Operator's Manual Storage21
Tractor Orientation22
Safety Precautions (Read this for Safety before Using)23
Notices before Using the Tractor23
Notices When Starting Engine27
Notices While Operating/Using the Tractor28
Notices When Connecting Implement30
Notices When Towing the Tractor31
Notices When Transporting the Tractor31
Notices When Servicing the Tractor after Work32
Notices When Handling Diesel Fuel33
Notices When Leaving the Tractor34
Notices Relating to Toxic Substances34
Tractor Stability35
Ecology and the Environment38
Symbols40
Safety Decals41
Instructional Decals47
Long-Term Storage51
Preparation for Storage51
Check & Maintenance During Storage52
Preparation for Reuse53
Instruction for Safe Operation55
The Name of each Part55
Boarding and Exiting the Tractor56
Boarding the Tractor56
Driver's Seat57
Seat Adjustment58
Seat Belt58
Exiting the Tractor59
Safety Device60
Hood (Bonnet)60
Fender60
PTO Safety Cover and Protection Cap60
Roll-Over Protective Structure (ROPS) (Optional)61
Instruments and Controls65
Instrument Panel and Front Controls65
Instrument Panel67
Key Switch71
Turn Signal Light Switch72
Light Switch73
Hazard Warning Light Switch74
Horn Switch (if Fitted)75
PTO Switch (Independent PTO)76
Throttle Pedal (Mechanical)78
Clutch Pedal (Mechanical)78
Brake Pedals79
Parking Brake Lever80
HST Forward/Reverse Pedal (HST Type)81
Cruise Control Lever (HST Type)81
Left / Right-Hand Controls82
Main Gear Shift Lever83
Differential Lock Pedal83
Work Light Switch (if Fitted)84
Range Gear Shift Lever84
Four Wheel Driver Lever (4WD)85
Middle PTO Lever (if Fitted)85
Hydraulic System86
Safety Precautions86
Steering System87
Hydraulic Lift Control88
Remote Control Lever and Quick Coupler (if Fitted)90
Joystick Lever (if Fitted)91
Hydraulic System Diagram92
Operation and Work95
How to Handle New Tractor95
Check Points95
Notices in Handling New Tractor (Engine Brake-In Procedure)95
Engine Start and Stop96
Engine Start96
Start in Cold Weather98
Engine Stop99
How to Drive and Stop100
Transmission Warm-Up in Cold Weather100
How to Drive101
Changing Speed103
Emergency Stop104
Stopping Tractor105
Parking106
Transport on Public Roads (1) Safety Rules When Driving Tractor on the Roads107
Light Operation108
7-Pole Connector (Optional)109
Notices When Towing the Tractor110
Notices When Transporting the Tractor112
Field Operations113
Rear 3-Point Linkage113
Power Take-Off (PTO) Operation117
Hitch and Drawbar (Optional)120
Technically Maximum Permissible Mass121
Tires and Load Capacity122
Adjusting Wheel Tracks and Tire Replacement123
Using Front-End Loader (if Fitted)126
Adjusting Steering Angle129
Recommended Maximum Specification of Implements130
Ballasting Weights (Optional)131
Driving Speed134
Lubrication and Maintenance135
General Information135
Tightening Torque for Normal Assembly136
Standard Torque Data for Hydraulics138
General Specification - Diesel Fuel141
Biodiesel Fuel142
Refueling the Tractor144
Change Engine Coolant to Organic Acid Technology (OAT) Coolant145
Access for Maintenance146
Maintenance Chart147
Lubricants and Capacity151
First 50 Hour Check152
When the Warning Indicator Lights153
Engine Oil Pressure Indicator153
Battery Charging Indicator153
Check before Starting (Daily Check)154
Engine Oil154
Fuel Tank155
Instrument Panel & Indicators155
Turn Signal Lights, Lights and Horn156
Engine Coolant157
Air Cleaner (Dry Type)157
Cleaning of Radiator and Radiator Screen158
Tire Air Pressure & Damage158
Tightening State of Bolts and Nuts of each Part159
Adjustment of Clutch Pedal Play (Mechanical Type)160
Adjustment of Brake Pedal Play161
Adjusting HST Control Linkage (HST Type)162
Checking Fuel Filter Element163
Every 50 Hour Check164
Lubricating Grease Nipple164
Cleaning of Radiator and Radiator Screen164
Checking Transmission Oil165
Checking Front Axle Oil165
Battery Check165
Air Cleaner (Dry Type)165
Hydraulic Hoses and Leakage166
Every 100 Hour Check167
Checking and Adding Engine Oil167
Every 250 Hour Check168
Replacing Engine Oil and Filter168
Replacing Hydraulic Oil Filter169
Tension Adjustment of Engine Belt170
Toe-In170
Cleaning Fuel Tank171
Every 500 Hour Check172
Changing Front Axle Oil172
Changing Transmission Oil172
Replacing Fuel Filter Element173
Replacing Air Cleaner Element (Dry Type)173
Adjusting Engine Valve Clearance174
Checking Nozzle Injection Pressure174
Every 2-Year Check175
Replacing Engine Coolant175
General Maintenance (When Required)178
Air-Bleeding from Fuel System178
Fuse & Main Fuse181
Battery Handling and Notices183
Alternator and Drive Belt - Check187
Tail/Brake Light Bulb and Turn Signal Light Bulb- Replace188
Headlight Bulb - Replace190
Touch-Up Paint Color191
Troubleshooting192
Engine Manufacturer's Warranty198
Dimension and Specification205

LS tractor MT225E - Page 128

Table of Contents

Related product manuals