LS tractor MT458 - Page 154

To Next Page

To Previous Page

4 -32

③ Attaching points for Front-end loader

 When attaching the front-end loader, refer to the drawings as below.

(Unit : mm)

Main Page

Table of Contents11
General Notices for Safety17
Note to the Owner - General Information17
Before Using the Tractor19
Manual Scope and Required Training Level21
Metric and Imperial Units Abbreviations23
Product Identification Number (PIN)25
Operator's Manual Storage27
Tractor Orientation28
Safety Precautions (Read this for Safety before Using)29
Notices before Using the Tractor29
Notices When Starting Engine33
Notices While Operating/Using the Tractor34
Notices When Connecting Implement36
Notices When Towing the Tractor37
Notices When Transporting the Tractor37
Notices When Servicing the Tractor after Work38
Notices When Handling Diesel Fuel39
Notices When Leaving the Tractor40
Notices Relating to Toxic Substances40
Tractor Stability41
Ecology and the Environment44
Symbols46
Safety Decals47
Instructional Decals55
Long-Term Storage60
Preparation for Storage60
Check & Maintenance During Storage61
Preparation for Reuse62
Instruction for Safe Operation63
The Name of each Part63
Boarding and Exiting the Tractor65
Boarding the Tractor65
Seat Adjustment66
Seat Belt68
Tilting Steering Wheel69
Ventilation (Cabin Only)69
Exiting the Tractor70
Safety Device71
Hood (Bonnet)71
Fender71
PTO Safety Cover and Protection Cap71
Roll-Over Protective Structure (ROPS)72
Instruments and Controls75
Instrument Panel and Front Controls75
Instrument Panel76
Key Switch84
Turn Signal Light Switch85
Light Switch86
Hazard Warning Light Switch87
Horn Switch(Optional)88
Grille Work Light Switch88
DPF Switch89
PTO Switch94
PTO Mode Switch (Optional)94
Shuttle Lever (Synchro-Shuttle)95
Throttle Lever95
Throttle Pedal96
Clutch Pedal96
Brake Pedals97
Beacon Lamp Switch (if Fitted)98
Right-Hand Controls and Cabin Pillar99
Main Gear Shift Lever99
Creeper Gear Lever (if Fitted)100
Differential Lock Pedal100
Work Light Switch101
Window Wiper&Washer Switch (Cabin Type)102
Electrical Power Outlet Socket (Cabin Only)103
Indoor Light (Cabin Only)103
Audio Player (Cabin Only) (if Fitted)103
ESC Main Switch104
ESC Speed Up/Down Switch105
ESC Mode Select Switch105
Left-Hand Controls106
Range Gear Shift Lever106
PTO Gear Lever (Optional)107
Four Wheel Drive Lever (4WD)107
Parking Brake Lever108
Power Shuttle System (PSS) (if Fitted)109
Power Shuttle Lever (PSS)109
Clutch Pedal (PSS)111
PSS Mode Select Switch (PSS)112
Error Diagnosis Code (PSS)113
Hydraulic System114
Safety Precautions114
Steering System115
Hydraulic Lift Control (MHL)115
Remote Control Lever and Quick Coupler (Optional)118
Joystick Lever (Optional)120
Auto Lift Control (MHL, if Fitted)121
Hydraulic System Diagram122
Operation and Work123
How to Handle New Tractor123
Check Points123
Notices in Handling New Tractor (Engine Brake-In Procedure)123
Engine Start and Stop124
Engine Start124
Start in Cold Weather125
Engine Stop126
How to Drive and Stop127
Transmission Warm-Up in Cold Weather127
How to Drive128
Changing Speed130
Emergency Stop130
Stopping Tractor131
Parking132
Handling Turbocharger (if Fitted)132
Transport on Public Roads133
Safety Rules When Driving Tractor on the Roads133
Light Operation134
7-Pole Connector (Optional)136
Notices When Towing the Tractor137
Notices When Transporting the Tractor139
Field Operations140
Rear 3-Point Linkage140
Power Take-Off (PTO) Operation144
Hitch and Drawbar (Optional)146
Technically Maximum Permissible Mass147
Tires and Load Capacity148
Adjusting Wheel Tracks and Tire Replacement149
Using Front-End Loader (if Fitted)152
Adjusting Steering Angle155
Recommended Maximum Specification of Implements156
Ballasting Weights (Optional)157
Working in Hazardous Area160
Driving Speed161
Lubrication and Maintenance163
General Information163
Tightening Torque for Normal Assembly164
Standard Torque Data for Hydraulics166
General Specification - Diesel Fuel169
Biodiesel Fuel170
Refueling the Tractor172
Change Engine Coolant to Organic Acid Technology (OAT) Coolant173
Access for Maintenance174
Maintenance Chart175
Lubricants and Capacity177
First 50 Hour Check178
When the Warning Indicator Lights179
Drain Water from Fuel Filter179
Hydraulic Oil Pressure Indicator (Optional)180
Engine Oil Pressure Indicator180
Battery Charging Indicator180
Check before Starting (Daily Check)181
Engine Oil181
Fuel Tank182
Instrument Panel & Indicators182
Turn Signal Lights, Lights and Horn183
Engine Coolant184
Air Cleaner (Dry Type)184
Cleaning of Radiator and Radiator Screen185
Tightening State of Bolts and Nuts of each Part186
Adjustment of Clutch Pedal Play (Mechanical Type)187
Adjustment of Brake Pedal Play188
Every 50 Hour Check189
Lubricating Grease Nipple189
Cleaning of Radiator and Radiator Screen189
Checking Transmission Oil190
Checking Front Axle Oil190
Battery Check191
Air Cleaner (Dry Type)191
Hydraulic Hoses and Leakage191
Cleaning Cabin Air Filters191
Every 100 Hour Check192
Checking and Adding Engine Oil192
Every 300 Hour Check193
Replacing Engine Oil and Filter193
Replacing Hydraulic Oil Filter194
Tension Adjustment of Fan Belt195
Toe-In195
Cleaning Fuel Tank196
Every 500 Hour Check197
Replacing Fuel Filter Cartridge197
Replacing Air Cleaner Element (Dry Type)198
Replacing Cabin Air Filters199
Every 600 Hour Check200
Changing Front Axle Oil200
Changing Transmission Oil201
Every 1000Hr or 1-Year Check202
Adjusting Engine Valve Clearance202
Checking Nozzle Injection Pressure202
Every 1500Hr or 2-Year Check203
Replacement of Engine Coolant203
Cleaning Emission Related Parts206
Every 3000Hr Check207
Cleaning Emission Related Parts207
General Maintenance (When Required)208
Air-Bleeding from Fuel System208
Fuse & Main Fuse211
Battery Handling and Notices213
Alternator and Drive Belt - Check217
Tail/Brake Light Bulb and Turn Signal Light Bulb- Replace218
Headlight Bulb - Replace220
Touch-Up Paint Color221
Troubleshooting222
Air Conditioning System227
The Name of each Part of Cooling and Heating System227
How to Use Air Conditioner and Heater228
How to Operate Air Conditioner and Heater228
Air Direction Control228
Every 6 Month Check229
Checking Refrigerant Amount229
Cleaning Condenser and Radiator Screen229
Checking Leakage229
Belt Tension Adjustment230
Cleaning and Replacing Cabin Air Filters230
Every Year Check231
Compressor Check231
Control Switch Check231
Troubleshooting232
System Diagram234

LS tractor MT458 - Page 154

Table of Contents

Related product manuals