Lukas HT 90 - 9 Repairs; General Information; Preventative Service

17
9.2.1 Care instructions
Theexterioroftheequipmentistobecleanedfromtimetotimeinordertoprotectitfrom
externalcorrosion.Oilistobeappliedtothemetallicsurfaces.
9.2.2 Function and load test
Ifthereisanydoubtregardingthesafetyorreliabilityoftheequipment,afunctionandload
testmustalsobeperformed.
9. Repairs
9.1 General information
Servicing may only be carried out by the manufacturer or personnel trained by the
manufacturerandbyauthorisedLUKASdealers.
OnlyLUKASsparepartsmaybeusedtoreplaceallcomponents(seesparepartslist),as
specialtoolsandcompliancewithassemblyinstructions,safetyaspectsandinspectionsare
required(seealsochapter“MaintenanceandServicing”).
During assembly, ensure that all components are particularly clean, since dirt can
damage the rescue equipment!
WARNING / CAUTION / ATTENTION!
Protective clothes must be worn when repairs are being carried out, as the
devicesmayalsobepressurisedwhennotinoperation.
NOTE:
AlwaysregisteryourdeviceontheLUKASHydraulikGmbHwebsite.Thisisthe
onlywaytoguaranteeyourextendedwarrantycover.
NOTE:
You should always contact LUKAS or an authorised dealer before using
couplingsfromanothermanufacturer.
ATTENTION!
BecauseLUKASrescueequipmentsareappropriateforhighestachievements,
onlycomponentsmaybeexchanged,whicharespeciedinthesparepartslist
oftheappropriateequipment.
Othercomponentsinthedevicemayonlybereplacedif:
- YouhaveparticipatedinanappropriateLUKASservicetrainingcourse.
- You have the explicit permission of LUKASCustomerService (on request,
vericationthatpermissionmaybegranted.Tobecheckedineachindividual
case!)
9.2 Preventative service
Afunctionaltestmustbecarriedoutafterrepairs:
Extendthedevice2-3timesintheunloadedstatesothatanyairpresentcanescapefrom
thesystem.