Lycomin 0-360 User Manual

TEXTRON
LYCOMING
OPERATOR'S
MANUAL
0-360 and ASSOCIATED MODELS
TROUBLE
Engine will not
Deliver
Rated
Power (Cont.)
PROBABLE CAUSE
Exhaust
bypass
con-
troller is in
need of adjust-
ment
Oil
pressure
too low
Inlet orifice
to actuator
clogged
Exhaust bypass con-
troller malfunc-
tion
Exhaust bypass
butterfly not
closing
Turbocharger
im-
peller binding
frozen or fouling
housing.
Piston seal in
actuator leak-
ing. (Usually
accompanied
by
oil leakage at
drain line)
Controller not
getting enough
oil pressure to
close the waste
gate
Chips under
metering valve
in controller
holding it
open
SECTION 6
REMEDY
Have exhaust bypass control-
ler adjusted.
Tighten fittings. Re-
place lines or hoses.
Increase
oil pressure
to desired pressure.
Remove inlet line at
actuator and clean
orifice.
Replace
unit.
Low pressure. Clogged
orifice in inlet to
actuator.
Butterfly shaft binding.
Check
bearings.
Check bearings. Replace
turbocharger.
Remove and replace
actuator
or disassemble
and
replace packing.
Critical Altitude
Lower than
Specified
Check pump outlet pres-
sure,
oil filters,
external
lines for leaks or ob-
structions.
Replace
controller.
6-7

Lycomin 0-360 Specifications

General

Brand	Lycomin
Model	0-360
Category	Engine
Language	English