FORKLIFT TRUCK MAINTENANCE
DAILY AND WEEKLY MAINTENANCE
IMPORTANT
THE OPERATOR IS AUTHORISED TO CARRY OUT THIS MAINTENANCE.
These maintenance operations enable the operator to maintain the lift truck in a clean and safe condition.
MANDATORY FIRST 500 HOURS OR 6 MONTHS SERVICE
IMPORTANT
THIS SERVICE MUST BE CARRIED OUT AFTER THE FIRST 500 HOURS OF SERVICE OR WITHIN THE 6 MONTHS FOLLOWING THE START-UP OF THE MACHINE
(WHICHEVER OCCURS FIRST).
PERIODIC MAINTENANCE
IMPORTANT
THE PERIODIC MAINTENANCE MUST BE CARRIED OUT BY A PROFESSIONAL APPROVED BY THE MANITOU NETWORK.
MAINTENANCE SCHEDULE
This schedule enables the operator to keep up with the periodic maintenance of the lift truck by notifying the total number
of hours of operation and the date of the service performed by the professional approved by the MANITOU network.
OCCASIONAL MAINTENANCE AND OPERATION
These maintenance tasks and operations are to be performed as required for the safety and upkeep of the lift truck.
DAILY AND WEEKLY MAINTENANCE
3 - 4
Â
10H - DAILY MAINTENANCE OR EVERY 10 HOURS OF SERVICE
- CHECK Lift truck environment ........................................................... 3-12
- CHECK Engine oil level .................................................................. 3-12
- CHECK Coolant level .................................................................... 3-13
- CHECK Fuel level ........................................................................ 3-13
- CLEAN Cyclonic pre-filter (option) ....................................................... 3-13
Â
50H - WEEKLY MAINTENANCE OR EVERY 50 HOURS OF SERVICE
- CHECK Alternator/fan/crankshaft belt tension............................................ 3-14
- CHECK Tyre pressures ................................................................... 3-14
- CHECK Wheel nut torques............................................................... 3-14
- CHECK Hydraulic oil level................................................................ 3-15
- CHECK Washer fluid level (option) ....................................................... 3-15
- CHECK - ADJUST Tension and alignment of the mast lifting chains.................................. 3-15
- CLEAN Radiator core .................................................................... 3-16
- CLEAN fuel pre-filter .................................................................... 3-16
- CLEAN/CHECK Dry air filter cartridge ............................................................ 3-17
- GREASE General greasing ................................................................ 3-18
- CHECK Hydraulic oil..................................................................... 3-20
647635 (12/12/2017)
To Next Page
Loading...
Need help?
General
