48 Part Number 000014141 Rev 11 12/23
Maintenance Section 4
,
Caution
Use only Manitowoc approved Ice
Machine De‑scaler and Sanitizer for this
application (Manitowoc De‑scaler part
number 9405463 and Manitowoc Sanitizer
part number 9405653). It is a violation of
Federal law to use these solutions in a
manner inconsistent with their labeling.
Read and understand all labels printed on
bottles before use.
Detailed De‑scaling and Sanitizing
Procedure
Ice machine De‑scaler is used to remove
lime scale and mineral deposits. Ice
machine sanitizer disinfects and removes
algae and slime.
NOTE: Although not required and
dependent on your installation, removing
the ice machine top cover may allow easier
access.
Step 1 Open the front panel to access
the evaporator compartment. Ice must not
be on the evaporator during the de‑scaling/
sanitize cycle. Follow one of the methods
below:
• Press the power switch at the end of
a harvest cycle after ice falls from the
evaporator(s).
• Press the power switch and allow the ice
to melt.
Notice
Never use anything to force ice from the
evaporator. Damage may result.
Step 2 Remove all ice from the bin/
dispenser.
Step 3 Press the Clean button and select
“Turn off when complete”. Water will flow
through the water dump valve and down
the drain. Wait approximately 1 minute
until the water trough refills and the display
indicates Add Chemical. Add the proper
amount of ice machine de‑scaler to the
water trough by pouring between the
water curtain and evaporator, then confirm
the chemical was added.
,
Caution
Do not mix De‑scaler and Sanitizer
solutions together. It is a violation of
Federal law to use these solutions in a
manner inconsistent with their labeling.
n
Warning
Wear rubber gloves and safety goggles
(and/or face shield) when handling Ice
Machine De‑scaler or Sanitizer.
Model
Amount of
De‑scaler
IT0300/IP0320
IT0420/IT0620
3 oz
(90 ml)
IT0450/IT0500/IF0500
IP0500/IF0600/IF0600C
IT0750/IF0900/IF0900C
IT0900/IT1200/IT1200C
5 oz
(150 ml)
IBF0620C/IBF0820C
IBT1020C
5 oz
(150 ml)
IF1400C/IT1430C
IT1500
IF1800C/IT1830C
IT1900
IF2100C/IT2130
9 oz
(265 ml)
To Next Page
Loading...
Need help?
General