MAREDO ST Series - Maintenance

10
7.0 Maintenance
On each STrac 700 an Hour/tach meter is located below the air filter.
Follow maintenance according to the interval as shown in the table below:
STrac 700
Before
each
use
Every
8
hours
Every
50
hours
Every
100
hours
Every
Year
Every
500
hours
Clean air filter
X
Replace air filter
X
Check engine oil
level
X
Change motor oil
X or
X
Check hydraulic oil
level
X
Change hydraulic
oil + replace filter
X or
X
Check tyre pressure
X
Grease PTO
X
Grease steering pin
X
Check and tension
V-belts
X
Check Emergency
stop
X
Check and re-
adjust handbrake
X
Check and tension
pump chain drive
X
7.1 Clean air filter: Remove the top nut of the plastic air filter housing.
Remove the air filter housing and remove the nut which holds the air
filter. Take the air filter out and clean it carefully with compressed air
blowing from the inside to the outside of the filter. Always replace
damaged air filters. Replace air filters once a year or every 500 hours.
7.2 Check oil level: see 5.1.2
7.3 Replenish motor oil: Take precautions to prevent oil spills. Carefully
remove the oil drain plug from the bottom of the engine. Let all oil drain
into an oil pan. When all oil is out, re-insert the drain plug and carefully
fill the engine with the correct engine oil (see 2.0 Technical specifications)
For checking the oil level see 5.1.2.