5.
Storage
a.
Remove and clean battery, following correct procedures.
b.
Bring battery to full charge, following charger manufacturer’s instructions.
c.
Store in a cool dry place where there is no possibility of freezing.
NOTE: Check battery every 30 days during storage and return to full charge if necessary.
Engine and Engine Filters
1.
Initial Break-In
Proper break-in procedures are a must to realize maximum engine power output and
longest engine life. Engine should show noticeable power gain through the first 30
hours service. Power gain will continue until approximately 200 hours if properly
broken-in.
IMPORTANT: Do not operate engine above 3/4 throttle for the first 25 hours.
IMPORTANT: Do not ‘lug’ engine during the break-in period.
IMPORTANT: Replace the original oil and oil filters after the first 20 hours of operation.
2.
Fuel Filters
Both fuel filters are disposable.
CAUTION: BOTH DIESEL FUEL AND GASOLINE ARE HIGHLY FLAMMABLE AND
EXPLOSIVE UNDER CERTAIN CONDITIONS. DO NOT SMOKE OR ALLOW
SPARKS OR OPEN FLAME WHEN HANDLING.
a.
To Change:
i.
Stop engine. Wait 15 minutes for engine and surrounding parts to cool before
proceeding.
ii.
Unscrew and discard existing filters.
iii.
Fill new filter with clean fuel.
iv.
Lightly coat the seal ring with oil, then screw on filter until seal meets flange.
v.
Tighten an additional 1/2 to 3/4 turn by hand.
IMPORTANT: Do not over tighten.
b.
Oil and Filter Changing:
To Next Page
Loading...