Mendota AA-11-02470 - User Manual

85-03-01057-P FV44i Gen 3
Installation and Operating Instructions
MODEL NO. AA-11-02470 FV44I Gen 3 FULLVIEW DIRECT VENT GAS FIREPLACE INSERT HEATER
WARNING: If the information in these instructions
is not followed exactly, a fire or explosion may
result causing property damage, personal injury, or
loss of life.
AVERTISSEMENT. Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire au
minimum le risque d'incendie ou d'explosion ou pour
éviter tout dommage matériel, toute blessure ou la mort.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call
the fire department.
- Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
Ne pas entreposer ni utiliser d'essence ni d'autres vapeurs
ou liquids inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bâtiment où vous trouvez.
• Appelez immédiatement votre fournisseur de gaz depuis
un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incendies.
- L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by local
codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not
convertible for use with other gasses unless a
certified kit is used.
Cet appareil peut être installé dans une maison
préfabriquée (É.-U. seulement) ou mobile déjà installée à
demeure si les règlements locaux le permettent.
Cet appareil doit être utilisé uniquement avec les types de
gaz indiqués sur la plaque signalétique. Une trousse de
conversion est fournie avec cet appareil.
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this appliance
and must be installed.
Une barrière conçue pour réduire le risque de brûlures
du verre chaud est fournie avec cet appareil et doit être
installée.

Summary

READ ME FIRST

1.1 INITIAL FIRING AND CURING PROCEDURE

Procedure for initial heat curing cycle to burn off manufacturing materials and harden paint.

1.2 HOT SURFACES ARE NORMAL

Information about safe operating temperatures and warnings regarding hot surfaces.

GENERAL INFORMATION

2.1 SAFETY AND WARNING INFORMATION

General safety guidelines, building permits, and other critical cautions.

2.2 SAFETY WARNINGS

Specific warnings related to product use, fuel, installation, and safety.

2.3 REQUIREMENTS FOR THE COMMONWEALTH OF MASS.

Specific installation requirements for Massachusetts, including CO detectors.

TECHNICAL REFERENCES

3.1 GENERAL TECHNICAL REFERENCES

General technical information and pre-ignition checks for installation.

3.2 MECHANICAL TECHNICAL REFERENCES

Technical specifications and requirements for mechanical installation.

3.2.1 Install Only in Woodburning fireplaces

Requirement to install the insert only in specific types of woodburning fireplaces.

3.2.4 FV44 i Insert Ratings Information

Specific ratings and specifications for the FV44i Insert model.

3.2.11 Clearances to Combustible Side Walls

Requirements for maintaining safe clearances from combustible side walls.

3.2.13 Hearth Pad Requirement

Requirements for hearth pad installation and materials.

3.2.19 Venting

Instructions and requirements for venting the fireplace insert.

3.3 ELECTRICAL TECHNICAL REFERENCES

Technical information regarding the electrical requirements and connections.

3.4 PLUMBING TECHNICAL REFERENCES

Technical information related to gas supply requirements and connections.

3.4.1 Gas Supply Requirements

Essential requirements for gas supply pressure and line sizing.

3.4.2 Gas Supply Line Sizing

Tables and instructions for correctly sizing gas supply lines.

INSTALLATION INSTRUCTIONS

4.1 INSTALLATION CHECKLIST

A comprehensive checklist for installers to ensure all steps are completed.

4.2 UNPACKING THE INSERT

Step-by-step instructions for safely unpacking the fireplace insert.

4.7 LEVELING BOLTS

Information on leveling bolts and their installation for proper unit placement.

4.8 GLASS DOOR REMOVAL AND REINSTALLATION

Step-by-step guide for removing and reinstalling the glass door.

4.10 NATURAL GAS TO LPG CONVERSION

Detailed instructions for converting the appliance from Natural Gas to LPG.

4.11 FIREPLACE CAVITY PREPARATION

Steps for preparing the existing fireplace cavity for insert installation.

4.12 VENTING

Critical instructions and warnings regarding the proper installation of the vent system.

4.12.2 Dropping Flex Vent Liners

Instructions for installing flex vent liners into the chimney system.

4.14 INSERT BODY INSTALLATION

Step-by-step guide for installing the main insert body into the fireplace.

4.15 LIGHTING CHECKLIST

A checklist for final checks before operating the fireplace.

4.16 AIR SHUTTER CONTROL AND FLAME APPEARANCE

How to adjust air shutters for optimal flame appearance and performance.

HOMEOWNER INFORMATION

5.3 IMPORTANT INFORMATION FOR HOMEOWNER

Highlights crucial information for homeowners before operation.

5.4 OPERATING INFORMATION

General information and tips for operating the fireplace.

5.4.1 Using Your Remote Control

Instructions on how to use the remote control for fireplace operation.

5.4.3 Remote Control Functions

Explanation of the various functions controllable via the remote.

5.5 REMOTE CONTROL OPERATING INSTRUCTIONS

Detailed instructions for operating the fireplace using the remote control.

5.5.3 Understanding Your Remote-Control Icons

Explanation of icons and indicators on the remote control display.

5.6 IPI AND PILOT ON DEMAND MODES

Explanation of Intermittent Pilot Ignition (IPI) and Pilot on Demand (CPI) modes.

5.7 FIRST TIME LIGHTING INSTRUCTIONS

Instructions and safety warnings for the initial lighting of the fireplace.

5.10 FREQUENTLY ASKED QUESTIONS

Answers to common questions regarding operation and troubleshooting.

5.10.1 What to do if I smell gas?

Emergency steps to take if a gas smell is detected.

5.10.4 What maintenance is required?

Overview of required maintenance procedures for the fireplace.

5.10.12 Why wont my fireplace turn on?

Troubleshooting steps for when the fireplace fails to turn on.

MAINTENANCE INFORMATION

6.1 REQUIRED PERIODIC INSPECTIONS

Checklist and procedures for periodic inspections of the fireplace system.

6.3 REQUIRED ANNUAL MAINTENANCE

Procedures for annual maintenance tasks by a qualified professional.

6.4 OVER FIRING OR UNDER FIRING OF BURNER

Warnings and consequences of improper burner firing.

6.7 REPLACEMENT PARTS INFORMATION

Information on obtaining replacement parts and a list of common parts.

6.7.1 Replacement Parts List

A detailed list of available replacement parts for the appliance.

6.7.4 Gas Valve Train Parts

Identification of parts comprising the gas valve train.

WARRANTY QUALIFICATION AND SERVICE

7.1 FINAL INSTALLATION AND HOMEOWNER CHECKLIST

A checklist for final installation and homeowner understanding.

7.2 WARRANTY POLICY STATEMENT

Details of the limited lifetime warranty policy and coverage periods.

7.3 CONDITIONS

Conditions and owner responsibilities related to the warranty.

7.3.1 Exclusions

Specific exclusions from the warranty coverage.

7.3.3 How to Obtain Warranty Service

Steps for obtaining warranty service and contacting Mendota.

7.3.4 Owner Registration

Instructions for registering the product to activate the warranty.

Mendota AA-11-02470 Specifications

General

Category	Indoor Fireplace
Model	AA-11-02470
Fuel Type	Natural Gas or Propane
Ignition Type	Electronic Ignition
Vent Type	Direct Vent
Warranty	Limited Lifetime Warranty
Material	Steel