Mendota FV42 - User Manual

85-03-01109-J FV42
Installation and Operating Instructions
MODEL NO. AA-11-03792 FV42 FULLVIEW DIRECT VENT GAS FIREPLACE HEATER
WARNING: If the information in these instructions
is not followed exactly, a fire or explosion may
result causing property damage, personal injury or
loss of life.
AVERTISSEMENT. Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire au
minimum le risque d'incendie ou d'explosion ou pour
éviter tout dommage matériel, toute blessure ou la mort.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call
the fire department.
- Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
Ne pas entreposer ni utiliser d'essence ni d'autres vapeurs
ou liquids inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bâtiment où vous trouvez.
• Appelez immédiatement votre fournisseur de gaz depuis
un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incendies.
- L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by local
codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not
convertible for use with other gasses, unless a
certified kit is used.
Cet appareil peut être installé dans une maison
préfabriquée (É.-U. seulement) ou mobile déjà installée à
demeure si les règlements locaux le permettent.
Cet appareil doit être utilisé uniquement avec les types de
gaz indiqués sur la plaque signalétique. Une trousse de
conversion est fournie avec cet appareil.
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this appliance
and must be installed.
Une barrière conçue pour réduire le risque de brûlures
du verre chaud est fournie avec cet appareil et doit être
installée.

Summary

READ ME FIRST

CAUTION STATEMENTS TO PARENTS OF YOUNG CHILDREN

Warnings regarding young children and the fireplace's heat output.

INITIAL FIRING AND CURING PROCEDURE

Instructions for the initial heat curing cycle to burn off manufacturing residues.

HOT SURFACES ARE NORMAL

Information about normal operating temperatures of fireplace surfaces.

PERIODIC AND ANNUAL CLEANING ARE REQUIRED

Requirements for regular cleaning and maintenance of the appliance.

GENERAL INFORMATION

SAFETY AND WARNING INFORMATION

Essential safety guidelines and warnings for installation and use.

SAFETY WARNINGS

Critical safety warnings, including chemical exposure and installation risks.

REQUIREMENTS FOR THE COMMONWEALTH OF MASS.

Specific installation requirements for Massachusetts.

TECHNICAL REFERENCES

GENERAL TECHNICAL REFERENCES

General information, curing instructions, and material requirements.

MECHANICAL TECHNICAL REFERENCES

Planning, clearances, dimensions, and specific component details.

Fireplace Dimensions and Clearances

Specifications for fireplace physical measurements and clearance requirements.

Venting Systems and Components

Information on vent system types, connections, and component identification.

ELECTRICAL TECHNICAL REFERENCES

AC power requirements, wiring, and DC backup power connection.

PLUMBING TECHNICAL REFERENCES

Gas supply requirements, sizing, pressure, and conversion procedures.

INSTALLATION INSTRUCTIONS

INSTALLATION CHECKLIST

A step-by-step guide for installers to ensure proper setup.

Unpacking and Unit Preparation

Steps for removing the fireplace from packaging and preparing it for installation.

Gas Conversion and Lighting

Procedures for fuel conversion, burner adjustments, and initial lighting.

Vent System Installation

Detailed instructions for installing various vent configurations and caps.

LOG SET; MEDIA INSTALLATION

Instructions for installing log sets or other media.

AIR SHUTTER CONTROL AND FLAME APPEARANCE

Adjustments for air shutters to achieve optimal flame appearance.

HOMEOWNER INFORMATION

AESTHETIC CONSIDERATIONS

Information on visual aspects and decorative options for the fireplace.

HEATING PERFORMANCE

How the fireplace heats a space and how to adjust heat output.

OPERATING INFORMATION

Guidance on using the remote control and basic operation.

REMOTE CONTROL FUNCTIONS

Detailed explanation of remote control buttons and their functions.

IPI AND CPI MODES

Explanation of intermittent vs. continuous pilot ignition modes.

FREQUENTLY ASKED QUESTIONS

Answers to common questions regarding operation and troubleshooting.

MAINTENANCE INFORMATION

REQUIRED PERIODIC INSPECTIONS

Checks to perform periodically for safety and performance.

CLEANING VIEWING GLASS

Instructions for cleaning the fireplace glass safely and effectively.

REQUIRED ANNUAL MAINTENANCE

Annual procedures to ensure the fireplace operates correctly and safely.

REPLACEMENT PARTS INFORMATION

Information on accessing and identifying replacement parts.

WARRANTY QUALIFICATION AND SERVICE

FINAL INSTALLATION AND HOMEOWNER CHECKLIST

Verification steps for proper installation and homeowner training.

WARRANTY POLICY STATEMENT

Details on warranty coverage, terms, and conditions.

How to Obtain Warranty Service

Steps for contacting support and processing warranty claims.

Owner Registration

Instructions for registering the product to activate the warranty.

Mendota FV42 Specifications

General

Model	FV42
Fuel Type	Natural Gas or Liquid Propane
Vent Type	Direct Vent
Glass Front	Yes
Product Type	Gas Fireplace
Log Material	Ceramic Fiber
Thermostat Compatibility	Yes
Type	Fireplace
Efficiency	Up to 76.7%
Dimensions	42" Wide
Venting	Direct Vent
Ignition Type	Electronic Ignition
Warranty	Limited Lifetime
BTU Input	42, 000 BTU