Mendota SEABROOK D-40 User Manual

MENDOTA "SEABROOK"
DIRECT VENT
GAS FIREPLACE INSERT
WITH
HEARTHGLO COMBUSTION SYSTEM
Model D-40 Deep Timber: Flat or Bay
(D40 Flat shown with optional Andover Door and Overlay)
INSTALLATION & OPERATING INSTRUCTIONS
NO. DT-0704
WARNING: THIS APPLIANCE TO BE USED ONLY AS AN INSERT IN
SOLID FUEL BURNING FIREPLACES.
AVERTISSEMENT: Cet appareil a etre employe seulment comme un inserer dans
lecarburant solide brulant des cheminees.
NOTE: THE NATURAL VENT (B-VENT) SYSTEM CANNOT BE USED TO VENT THIS INSERT MODEL!
WARNING: This product must be installed by a licensed plumber or gas fitter when installed in the commonwealth of Massachusetts. Improper installation,
adjustment, alteration, service or maintenance can cause injury or property damage. Refer to this manual. For assistance or additional information consult a
qualified installer, service agency or the gas supplier.
FOR YOUR SAFETY: DO NOT STORE OR USE GASOLINE OR OTHER
FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY
OTHER APPLIANCE.
POUR VOTRE Sécurité: Ne pas entreposer ni utiliser d’essence ni d’autre vaperures ou liquides
inflammables dans le voisinage de cet appareil ou de tout autre appareil.
FOR YOUR SAFETY: WHAT TO DO IF YOU SMELL GAS:
1. OPEN WINDOWS.
2. DON'T TOUCH ELECTRICAL SWITCHES.
3. DO NOT USE ANY PHONE IN YOUR BUILDING
4. EXTINGUISH ANY OPEN FLAME
5. IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR'S
PHONE.
6. FOLLOW THE GAS SUPPLIERS INSTRUCTIONS.
7. IF GAS SUPPLIER IS UNAVAILABLE, CALL YOUR FIRE DEPARTMENT.
POUR VOTRE Sécurité:
Que faire si vous sentez une odeur de gaz:
1. Ne pas tenter d’allumer d’appareil
2. Ne touchez à aucun interrupteur. Ne pas vous servir des télé phones se trouvant dans le
batiment ou vous vous trouvez.
3. Evacuez la pièce, le bâtiment ou la zone.
4. Appelez immédiatement votre fournisseur de gaz depuis un voisin. Suivez les instructions du
fournisser.
5. Si vous ne pouvez rejoindre le fournisseur de gas, appelez le service dos incendies.
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION,
SERVICE OR MAINTENANCE CAN CAUSE INJURY OR PROPERTY
DAMAGE. REFER TO THIS MANUAL. FOR ASSISTANCE OR
ADDITIONAL INFORMATION, CONSULT A QUALIFIED INSTALLER,
SERVICE AGENCY, OR THE GAS SUPPLIER.
AVERTISSEMENT: Une installation, un réglage, une modification, un entretien ou une
maintenance incorrects peuvent entrainer des dommages matériels, des lésions corporelles ou la
perte de vies humaines. Consuter le manuel des usagers fourn avec ce generateur d’air chaud.
MISE EN GARDE: Installation, réglage, modification, entretien ou depannage non appropriés pourront causer des blessures ou des dommages materiels. Réferéz-vous au manuel du
proprietaire fourni avac cet appariel. Pour assistance ou renseignements complémentaires, veuillez consulter un installateur expérimenté, une agence dé depannage/entreitien ou cotre
compagnie gaziére. Pour utilisation avec les portes en verre certifiée l'appareil suelement. Ne pas opérer avec le verriére enlever, craquelure, brise.
f i r e - p a r t s . c o m

Mendota SEABROOK D-40 Specifications

General

Model	SEABROOK D-40
Category	Indoor Fireplace
Type	Direct Vent Gas Fireplace
Fuel Type	Natural Gas or Propane
BTU/hr Input	40, 000
BTU Input	40, 000
Venting	Direct Vent
Ignition	Electronic Ignition
Finish	Black
Width	42 inches

Summary

Fireplace Insert Introduction and Operation

General Information and Safety

Provides essential details about the fireplace insert, its operation, and crucial safety precautions.

Specifications and Clearances

Details the physical dimensions, clearances, and technical specifications required for safe installation.

Wall Switch, Remote Control or Thermostat Operation

Explains how to operate the fireplace using external controls like wall switches or thermostats.

Installation and Component Setup

Installation Instructions

Step-by-step guide for installing the gas fireplace insert into an existing fireplace.

Flue Venting

Details the methods and components for properly venting the fireplace insert to the outside.

Gas Supply Requirements and Pressure

Covers gas line sizing, pressure checks, and connection details for proper appliance operation.

Lighting Instructions

Comprehensive guide on how to safely light the pilot and main burner of the fireplace insert.

Deep Timber Log Set Installation

Instructions for properly placing the ceramic fiber log set for optimal flame appearance.

Blower Operation and Wiring

Explains the function, wiring, and operation of the dual hot air blowers included with the insert.

Natural to LP Gas Conversion

Details the procedure for converting the appliance from natural gas to propane.

Service, Support, and Compliance

Troubleshooting and Flame Adjustment

Addresses common issues, provides solutions, and guides on adjusting the flame appearance.

Maintenance Procedures

Outlines the annual maintenance required for the fireplace insert by a qualified service person.

Replacement Parts List

A comprehensive list of available part numbers and their descriptions for the Mendota D-40 Deep Timber.

Appliance Label Representation

Explains the information provided on the appliance's certification and rating label.

Warranty Information

Covers standard and extended lifetime warranties, conditions, and registration requirements.