L
Chapter 3 Cooling,
heating and air conditioning systems
Contents
Air conditioning system - check and maintenance . . . . . . . . . . . . . 14
Air conditioning system compressor - removal and installation . . . 16
Air conditioning system condenser - removal and installation . . . 17
Air conditioning system evaporator - removal and installation . . . . 18
Air conditioning system -general information . . . . . _ . . . . . . . . . . 13
Air conditioning receiver/drier - removal and installation . . . . . . . . 15
Antifreeze - general information . . . . . . . . . _ . . . . _ . . . . . . . . . . _ 2
Blower motor - removal and installation . . , . . . . . . . . . . . . . . . . . . 11
Coolant reservoir - removal and installation . . . . . . . . . . . . . . . . . . 6
Coolant temperature gauge sending unit-check
and replacement . . . . . . . . . . _ . . . . . _ _ , . . . . _ _ _ . . . . . _ _ . . . . 9
Cooling system servicing (draining, flushing
and refilling) ........................... $. ... See Chapter 1
Engine cooling fan and clutch - check and replacement ........ 5
General information
......................................
1
Heater/air conditioning control assembly - removal
and installation ...................................... 19
Heater core - removal and installation ............ _ .. _-. ...... 12
Heating system - general information
.................
_ ..... 10
Radiator - removal and installation .......................... 4
Thermostat - check and replacement ....................... 3
Waterpump-check.. .................................. 7 .’
Waterpump-replacement
................................ 8
Specifications
General
Coolant type and capacity . . . . . . . .
Thermostat opening temperature . .
Radiator cap pressure’rating . . . . .
Refrigerant capacity . : . . . . . . . . .
Torque specifications
Cooling fan bolts _ . . . . _ . . . .
Fan clutch bolts . . . . . . . . . _ . .
Water pump bolts
Small bolts.. . . . _ _ . . . . . . .
Large bolts . . . . . _ . . . . _ . .
Coolant temperature switch .
Coolant temperature sensor .
. .
. _
L .
. .
. .
. . . . .
. . . . ,
. . . . *
. . . . .
. . . . .
. . . . .
..-..
. . . . .
. . . . .
. . . . .
...............
...............
...............
...............
. . . . . . 1 . .
. . . _ . * . . .
. . . . . . . . . . . . . .
108 to 132 in-lbs
. . . . . 1.1. . . . . .
15to20
. . . . . _ L... . . . . .
22 to 29
. . . . . . . . .
. . . L.
14to29
. . . . .
. . . I.
See Chapter 1
180 to 195-degrees F
.- 12to15psi
Approx. 25 to 30 ounces
Ft-lbs (unless otherwise indicated)
84 to 108 in-lbs
” 72 to 84 in-lbs
To Next Page
Loading...
