Mitsubishi S16R2-PTAW User Manual

7-3
Chapter 7 MAINTENANCE SCHEDULE
Periodic Maintenance Chart for Regular (Prime) Use
Engine
Table 7-1 Periodic Maintenance Chart for Continuous Use Engine
Inspection and maintenance intervals and items inspected/maintained
Refer-
ence
page
Every 50 service hours or
every month
Fuel Tank - Drain Water *1 8-7
Water Separator - Drain Water *1 *2
First 50 service hours for
a new or overhauled
engine
Bolts and Nuts on the Engine Exterior - Retighten *2
Engine Oil, Oil Filter and Bypass Oil Filter - Replace
Engine oil analysis is also recommended at the same time.
The oil filters must also be replaced when the filter alarm light is turned on.
8-13
Every 250 service hours
Engine Oil, Oil Filter and Bypass Oil Filter - Replace
Engine oil analysis is also recommended at the same time.
The oil filters must be also replaced when the filter alarm lamp is turned on.
8-13
First 250 service hours
for a new or overhauled
engine
Valve Clearance - Inspect and Adjust
(Check valve mechanism at the same time.)
*2
Every 1000 service hours
Fuel Filter - Replace 8-10
Water Separator - Inspect and Replace *1 *2
Belt and Belt Tension - Inspect and Adjust 8-2
Gauze Filter - Clean 8-9
Every 2000 hours
Fuel Tank - Drain Water (Replace Parts As Needed) *1 8-7
Valve Clearance - Inspect and Adjust
(Check valve mechanism at the same time.)
*2
Fuel Injection Timing - Inspect and Adjust *2
Checking Movement of the Rack (during operation) of the fuel injection
pump (including the governor)
*2
Fuel Pipe - Inspect 8-12
Oil Pipe - Inspect 8-16
Fuel Injection Nozzle - Nozzle Tip Replacement (Check the spray condition
and adjust the fuel injection pressure after replacement)
*2
Every 4000 service hours
Top-End Engine - Overhaul
Remove the cylinder head, and perform inspection and maintenance around
the combustion chamber.
*2
Turbocharger - Inspect 8-21
Damper - Inspect 8-5
Starter - Inspect 8-26
Protection System - Inspect *2
Unit Seal and Oil Seal of water pump - Replace *2
LLC Concentration Level in the Coolant - Check *2

Mitsubishi S16R2-PTAW Specifications

General

Brand	Mitsubishi
Model	S16R2-PTAW
Category	Engine
Language	English