170 / 195
Service Manual Mitsubishi SL-Series diesel engines
Version 08/2004
ENGLISH
LUBRICATION AND MAINTENANCE CHART MAINTENANCE
170 / 195
MAINTENANCE
46 LUBRICATION AND
MAINTENANCE CHART
Recommended service should be performed at the
specified intervals. Under extremely severe, dusty or
wet operating conditions, more frequent lubrication
than is specified in this chart may be necessary.
Perform service on items at multiples of the original
requirement. For example, at Every 500 Service
Hours, also service those items listed under Every 100
(250) Service Hours, Every 50 Service Hours and
Every 10 Service Hours.
Interval Item Remarks (specifications) Page
Every 10 Service Hours
[Pre-Start Inspection]
Walk-around inspection See operation manual
Check engine oil level 172
Check fuel level See operation manual
Check coolant level See operation manual
Every 50 Service Hours
Drain water and sediment from the fuel
tank and water separator
See operation manual
Check the battery electrolyte level and
specific gravity
See operation manual
First 50 Service Hours
of New or
Reconditioned Engine
Change engine oil See SPECIFICATIONS (page 16) 173
Change oil filter 173
Retighten nuts and bolts 191
Every 100 Service
Hours
Clean fuel filter element After cleaning, prime 181
Clean radiator fins See operation manual
Every 250 Service
Hours or once a year
(whatever comes first)
Change engine oil See SPECIFICATIONS (page 16) 173
Change oil filter
173
Every 500 Service
Hours
Check and adjust valve clearance 0.25 mm (0.0098 in.) for both inlet and
exhaust valves
175
Change fuel filter element After changing, prime 180
Check and adjust injection pressure 140 kgf/cm
2
(1 991 psi) [13 729 kPa] 183
Check and adjust fan belt Deflection: 13 mm (0.5 in.) 184
Check glow plugs 133
Every 1000 Service
Hours
Retighten nuts and bolts 191
Check starter 115
Check alternator 122
Check turbocharger See turbocharger manual
Table 6 Lubrication and maintenance charts
To Next Page
Loading...
Need help?
General
