Mooney M20M - Page 4

MOONEY
AIRCRAFT
CORPORATION
M20M
SERVICE AND
MAINTENANCE MANUAL
INTRODUCTION
GROUP
This manual
provides
servicina
and
maintenance
information for
the
Mooney
Mlodel
M20M,
Serial
These
are
primary
divisions
of the
manual
that
enable
Numbers
27-0001
and
ON.
Maintenance
actions that
broad
separation
of
content,
ie.,
Airframe
systems
VS
Powerplant
systems.
These
groups
are
identified
by
tabs.
refer
to
a
limited
number of
aircraft
will
be
designated
by
serial number
of
applicable airplanes.
The
Part
Numbers
of
replacement
or
repair
parts
should be
SYSTEM/CHAPTER
identified
using
the illustrated
Paris
Catalog
applicable
to model
S/N
of aircraft
being
worked
on.
The
current
The
various
groups
contain
major
systems
information
P/N
can
be
ordered
through
any
Mooney Marketing
such
as
Right
controls,
landing
gear,
etc.
The
systems
Center
(MMC).
See
SECTION 91
for
exceptions
on
are
arranged
numerically
per
GAMA
recommended
electrical
components.
number
assignment,
It
is
suggested,
for
example,that
"Fuel"
be
identified
with
the
SystemlChapter
number
The
format and
contents
of this manual
are
prepared
in
"28".
accordance
with
GENERAL AVIATION
MANUFACTURER’S
ASSOCIATION
(GAMA)
The
sequence
of
numbers,
28-00-00,
refers
to
the
Specification
No.
2.
The
manual is
supplemented
with
General
information
of the
Fuel
Systems.
wiring
schematics for
the various
model
year
SUB-SYSTEM/SECTION
airplanes,as
necessary.
These
are
located in
Th,
major
systems
of
an
aircraft
are
broken
down
into
envelopes
at
the back
of
the manual
texts
pages.
sub-systems.
These
sub-systems
are
identified
by
the
NOTE
second
element
of
the
sequence
of
numbers,
ie.,
Revisions
or
reissues
to
this
28-20-00.
The
element
-20-
indicates the
distribution
portion
of the
fuel
system.
manual number
are
not
UNIT/SUBJECT
automatically
provided
to
manual
holders.
Holders
of
The
individual
units
within
a
sub-system
may
be identified
by
a
third dement
of
the
sequence
of
numbers,
these and
other
Mooney
ie.,28-20-01.
This number
is
assigned by
the
manufacturer
Technical
Publications
should
and
may
or
may
not
be
used
depending
upon
the
complete
the informatjon
on
the
c0mple~y
of
the
maintenance
action recommended.
YECLOW
CARD
located
at the
APPLICATION OF
NUMBERING SYSTEM
front of
the
Title
Page
and
send
MOO"ey
Aircraft
Corporation
prepares
all
applicable
to
Mooney
Aircraft
Corp_oratSon,
technical
publications
to
GAMA
format.
All
publications
concerning
maintenance
of
aircraft
will
conform
to
this
Louis
Sctitelner
Field,
Kerrville,
basic
numbering
system.
Any
person
wishing
TX.,
78028,
Attn:
Service
Parts
information
concerning
the
Fuel
Distribution
System
Department.
would
refer
to
the
pages
identified
as
28-20-00
in
any
maintenance
publication.
These
pages
will
be
numbered
sequentially
within
each
system
breakdown
Notification
is
sent
to
known manual holders when
in
the
current
Mooney
series
of
aircraft.
As
Mooney
another manual
is
prepared
to
replace
the
subscription
aircraft models become
more
complex
the
page
and advises
that
no more
revisions
will
be
sent out,
numbers
may
be
sequentially
numbered
within
The
new
manual
will
require
a new
subscription
sub-systems.
service.
If
additional Technical Publications
are
desired,
contact
the
Service
Parts
Department
at
The table
of
contents
in the
front of each
Mooney
Aircraft
Corporation
at
(830)
896-6000
UCT.
System/Chapter
will
provide
a
list
of
sub-systems
2092.
covered
in
the
Chapter.
For
example:
28-00
General
Correspondence
concerning
maintenance
or
part
numbers
on an
airplane
should contain the aircraft
28-10
Storage
model number and serial number. The serial number
CTanks,
vents,
repair, etc.)
appears
on
the identification
placard
located
on
the aft
end,
left
hand
side
of the
tailcone below the horizontal
28-20
Distribution
stabilizer.
(Boost
pumps,
fuel
lines,
etc.)
28-40
Indicating
ASSIGNMENT
OF
SUBJECT
MATERIAL
(Sender
Units,
quantity
gauges,
The
content
of
this
publication
is
organized
at
four
etc.)
levels:
If
there
is
a reason
to
distinguish
between
LEFT
HAND
Group
or
RIGHT HAND
fuel
quantity sending
units
then the
and
28-40-02
(Right
Hand).
This
concept
will
apply
to
number
would
be
expanded
to
28-40-01
(Left
Hand)
UnitlSubject
any
expanded
information
throughout
the
publications.
4-99
INTRODUCTION
OLDWILLWAYNE