Napoleon EPA 1100 User Manual

W415-1468 / A / 09.30.16
EN
FR
PG
45
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE.
This wood appliance needs periodic inspection and repair for proper operation. It is against United States federal
regulation to operate this wood appliance in a manner inconsistent with operating instructions in this manual.
INSTALLATION AND
OPERATING INSTRUCTIONS
1.27D
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)720-9081 • www.napoleonfi replaces.com • hearth@napoleonproducts.com
SAFETY INFORMATION
!
WARNING
If the information in these instructions is not followed exactly, a
fi re or explosion may result causing property damage, personal
injury or death. Improper installation, adjustment, alteration,
service or maintenance can cause injury or property damage,
bodily injury or even death. Please read entire manual before
you install and use your appliance.
This appliance has not been tested with an unvented gas log
set. To reduce risk of fi re or injury, do not install an unvented
gas log set into the appliance.
- This appliance can be very hot when burning.
- Combustible materials such as fi rewood, wet clothing, etc. placed too close
can catch fi re.
- Children and pets must be kept from touching the appliance when it is hot.
- The chimney must be sound and free of cracks. Before installing this unit,
contact the local building or fi re authority and follow their guidelines.
- Operate only with the door tightly closed.
- Burn wood behind the log retainer directly on the fi rebricks.
- Do not use an elevated grate or otherwise raise the fi re.
- At least 14 square inches (90.3 square centimeters) of outside air must be
admitted to the room or directly to the unit through a 4” (101.6mm) diameter
pipe.
- This appliance is designed to burn natural wood only. Higher effi ciencies and
lower emissions generally result when burning air dried seasoned hardwoods,
as compared to softwoods or to green or freshly cut hardwoods.
- Do not start a fi re with chemicals or fl uids such as gasoline, engine oil, etc.
- Do not burn trash or garbage, lawn clippings / waste, rubber, waste petroleum
products, paints or paint thinners / solvents, plastic, materials containing
asbestos, construction debris, railroad ties or treated wood, manure or animal
remains, salt water driftwood or salted materials, unseasoned wood, coal,
charcoal, coloured paper, cardboard, plywood or particleboard.
- Do not let the appliance become hot enough for any part to glow red.
- KEEP THE STOVE TOP TEMPERATURE BELOW 700°F (371°C). Attempts to
achieve heat output rates that exceed design specifi cations can result in steel
distortion and damage.
$10.00
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
!
WARNING
EPA 1100, 1150
1400, 1450 & 1900
PEDESTAL MODELS
MODELS 1100, 1150, 1400, 1450 & 1900 MEET THE 2015 U.S ENVIRONMENTAL PROTECTION AGENCY (E.P.A.) CRIB WOOD EMISSION LIMITS FOR WOOD
STOVES SOLD AFTER MAY 15, 2015, 40 C.F. R. PART 60. THESE STOVES HAVE BEEN TESTED AND LISTED BY INTERTEK TESTING SERVICES TO STANDARDS:
CSA B366.2, ULC S627, UL 1482. MODEL 1100 HAS BEEN TESTED AND LISTED FOR INSTALLATION IN MOBILE HOMES.

Napoleon EPA 1100 Specifications

General

Log Size	18 inches
EPA Certified	Yes
Firebox Material	Steel
Maximum BTU Output	65, 000 BTU
Efficiency	75%

Summary

Safety Information and Warnings

1.0 Installation Overview

2.0 Introduction and Appliance Details

2.1 Dimensions

Details the physical measurements of the appliance models.

2.2 Specifications

Lists technical specifications like heat output, capacity, and weight.

2.3 General Instructions

Provides essential guidelines for installation and initial use.

2.4 General Information

Explains the appliance's operation, combustion air, and safety warnings.

2.5 Rating Plate Information

Details the information found on the appliance's rating plate.

3.0 Pre-Installation Preparation

3.1 Appliance Placement

Guidelines for positioning the appliance safely and correctly.

3.2 Clearance to Combustibles

Specifies minimum safe distances from flammable materials.

3.3 Alcove Installation

Instructions for installing the appliance in an alcove.

3.4 Floor Protection

Requirements for non-combustible floor protection.

3.5 Outside Air

Information on connecting the appliance to an outside air source.

3.6 Mobile Home Installation

Regulations and requirements for mobile home installation.

4.0 Installation Procedures

4.1 Chimney Installation

General requirements and warnings for chimney installation.

4.1.1 Chimney Connection

Details on connecting the appliance to the chimney system.

4.1.3 Typical Through the Ceiling

Instructions for routing the chimney through a ceiling.

4.1.4 Typical Through the Wall

Instructions for routing the chimney through a wall.

5.0 Finishing

5.1 Door Removal / Installation

Steps for removing and reinstalling the appliance door.

5.2 Door and Handle Installation

Instructions for installing the door and handle.

5.5 Bricks and Baffle Installation

Guide for installing internal firebricks and baffles.

5.6 1150 Features

Highlights specific features of the 1150 model.

6.0 Optional Kit Installations

6.1 Optional Blower Kit Installation

Instructions for installing an optional blower kit.

7.0 Operation

7.1 Optimum Burn Method

Guidelines for efficient and clean wood burning.

7.2 Air Control

How to use and adjust the air control for draft and temperature.

7.3 Fire Extinguishers / Smoke & Carbon Monoxide Detectors

Safety recommendations for fire safety equipment.

7.4 Fuel and Lighting

Guidance on fuel selection and starting a fire.

8.0 Maintenance

8.1 Ash Removal Procedures

Safe methods for removing ashes from the appliance.

8.2 Creosote Formation and Removal

Explains creosote and how to prevent/remove it.

8.3 Runaway or Chimney Fire

Procedures and solutions for chimney fires.

8.5 Glass Replacement

Instructions for replacing the appliance glass.

8.10 Wood Fuel Information

Guidance on types of wood, moisture content, and storage.

9.0 Replacements and Parts Overview

9.1 EPA 1100 Overview

Illustrated parts list for EPA 1100 model.

9.2 EPA 1150 Overview

Illustrated parts list for EPA 1150 model.

9.3 EPA 1400 Overview

Illustrated parts list for EPA 1400 model.

9.4 EPA 1450 Overview

Illustrated parts list for EPA 1450 model.

9.5 EPA 1900 Overview

Illustrated parts list for EPA 1900 model.

10.0 Accessories

11.0 Troubleshooting

12.0 Warranty Information

13.0 Service History