Napoleon ROGUE 365 - User Manual

Other manuals for Napoleon ROGUE 365

Assembly Guide32 pages

Questions and Answers

B
bblanchardAug 16, 2025
Why is there excessive flare-ups or uneven heat on my Napoleon Grill?
- M
  Mario RussellAug 16, 2025
  Excessive flare-ups or uneven heat on your Napoleon Grill can occur due to several reasons: * Incorrectly installed sear plates: Ensure they are installed with the holes towards the front and the slots on the bottom. * Improper preheating: Always preheat the grill with both main burners on high for 10 to 15 minutes. * Excessive grease and ash build-up: Regularly clean the sear plates and drip pan. Do not line the drip pan with aluminum foil; refer to the cleaning instructions.
R
Rachel McdowellAug 19, 2025
Why is the heat low on my Napoleon ROGUE 365?
- P
  Pamela HicksSep 12, 2025
  If you're experiencing low heat or low flame on your Napoleon Grill when the valve is turned to high, it could be due to: * Improper lighting procedure (for propane): Ensure the lighting procedure is followed carefully. All gas grill valves must be in the off position when the tank valve is turned on. Turn the tank on slowly to allow pressure to equalize. Refer to the lighting instructions. * Undersized supply line (for natural gas): The pipe must be sized according to the installation code. * Improper preheating (for both gases): Preheat the grill with both main burners on high for 10 to 15 minutes.
D
Dawn JosephAug 22, 2025
What to do if burner output on high is too low on Napoleon Grill?
- C
  chad41Aug 22, 2025
  If the burner output on the 'high' setting is too low on your Napoleon Grill, and you notice a rumbling noise with a flute ring blue flame at the burner surface, it could be due to: * Lack of gas: Check the gas level in the propane cylinder. * Pinched supply hose: Reposition the supply hose as necessary. * Dirty or clogged orifice: Clean the burner orifice. * Spider webs or other matter in the venturi tube: Clean out the venturi tube. * Propane regulator in “low flow” state: Ensure the lighting procedure is followed carefully. All gas grill valves must be in the off position when the tank valve is turned on. Turn the tank on slowly to allow pressure to equalize. Refer to the lighting instructions.
J
janet37Aug 26, 2025
How to fix main burner that won't light with igniter on Napoleon ROGUE 365 Grill?
- J
  Jenna WilsonAug 26, 2025
  If the main burner on your Napoleon Grill won't light with the igniter but lights with a match, the jet-fire outlet may be dirty or clogged. Try cleaning the jet-fire outlet with a soft bristle brush.
M
marshchristinaAug 28, 2025
What to do if rear and side burners won't light with igniter on Napoleon Grill?
- C
  Crystal HernandezAug 28, 2025
  If the rear and side burners of your Napoleon Grill do not light with the igniter but will light with a match, the possible causes are: 1. Dead or incorrectly installed battery: Replace with a premium heavy-duty battery. 2. Loose electrode wire or switch terminal wires: Check that the electrode wire is firmly pushed onto the terminal on the back of the igniter and that the lead wires from the module to the ignition switch (if equipped) are firmly pushed onto their respective terminals. 3. Lifting flames on burner: Close air shutter slightly.
A
Alexander FranklinAug 31, 2025
Why do burners burn with yellow flame and smell of gas on Napoleon Grill?
- J
  James HillAug 31, 2025
  If the burners on your Napoleon Grill burn with a yellow flame and there's a smell of gas, it could be due to a possible spider web or other debris, or improper air shutter adjustment. Clean the burner thoroughly by removing it. Also, open the air shutter slightly according to the combustion air adjustment instructions. (Note: This adjustment must be done by a qualified gas installer.)
S
Samantha AndersonSep 3, 2025
Why do flames lift away from burner on Napoleon ROGUE 365 Grill?
- D
  dperkinsSep 3, 2025
  If the flames lift away from the burner on your Napoleon Grill, accompanied by the smell of gas and possible lighting difficulties, it may be due to improper air shutter adjustment. Close the air shutter slightly according to the combustion air adjustment instructions. (Note: This adjustment must be done by a qualified gas installer.)
W
Wanda GrahamSep 6, 2025
What to do if burners will not cross light each other on Napoleon Grill?
- W
  william62Sep 6, 2025
  If the burners on your Napoleon Grill will not cross light each other, it could be due to dirty or corroded cross light brackets. Clean or replace the brackets as required.
K
Krista EvansSep 9, 2025
Why does paint appear to be peeling inside lid or hood of Napoleon Grill?
- B
  Brooke WestSep 9, 2025
  If it appears that "paint" is peeling inside the lid or hood of your Napoleon Grill, it's likely hardened grease that has dried into paint-like shards and is flaking off. The finish on the lid and hood is porcelain and will not peel. Regular cleaning will prevent this.
T
Timothy WilliamsSep 12, 2025
Why is my Napoleon ROGUE 365 Grill regulator humming?
- A
  Amy PerezSep 12, 2025
  A humming regulator on your Napoleon Grill is a normal occurrence on hot days. It is caused by internal vibrations in the regulator and does not affect the performance or safety of the gas grill. Humming regulators will not be replaced as this is not a defect.

Summary

Napoleon Presidents 15 Year Limited Warranty

Conditions and Limitations

Details warranty coverage, normal private use, and exclusions for defects and damages.

Safe Operating Practices

General Operating Procedures

Guidelines for safe and proper operation, including assembly, location, and burner use.

Dimensions

General Information

Propane Cylinder Specifications

Details requirements for propane cylinders, including type, condition, and safety features.

Gas Hook-Up Instructions

Instructions for connecting gas supply, including cylinder connection and natural gas hook-up procedures.

Leak Testing Instructions

Performing a Leak Test

Step-by-step guide on how to check for gas leaks using soap and water solution.

Lighting Instructions

Main Burner Lighting

Procedure for lighting the main burners, including pilot light and match ignition.

Side Burner Lighting

Instructions for lighting the side burner, if applicable.

Cooking Instructions

Main Burner Use

Techniques for using main burners for searing, direct, and indirect cooking.

Direct Cooking

Method for cooking food directly over the heat source for searing.

Indirect Cooking

Method for cooking food using circulating heat, suitable for larger cuts.

Flame Side Burner Use

How to use the side burner for sauces, soups, and other cooking tasks.

Infrared Burner Operation and Care

Infrared Side Burner Operation

Instructions for operating and lighting the infrared side burner.

Protecting Infrared Burners

Steps to prevent ceramic burner cracking and damage.

Infrared Grilling Chart

Cleaning Instructions

Grids and Warming Rack Cleaning

Methods for cleaning cooking grids and warming racks.

Cast Iron Cooking Grids

Instructions for cleaning, seasoning, and daily use of cast iron grids.

Stainless Steel Cooking Grids

Guidance on cleaning and maintaining stainless steel cooking grids.

Control Panel Cleaning

How to clean the control panel without damaging the printing.

Infrared Burners Cleaning

How to clean debris from infrared burners after cooking.

Cleaning Inside the Grill

Steps for cleaning the interior of the grill, including debris removal.

Maintenance Instructions

Drip Pan Cleaning

Instructions for cleaning the drip pan and replacing the disposable grease tray.

Outer Grill Surface Cleaning

How to clean painted, porcelain, and stainless steel exterior surfaces.

Combustion Air Adjustment

Procedure for adjusting air shutters for optimal burner flame appearance.

Troubleshooting

Common Burner and Flame Issues

Diagnosing and resolving issues like low heat, flare-ups, yellow flames, and ignition problems.

Ordering Replacement Parts

Warranty Information

Details on how to provide necessary information for warranty claims and service.

Assembly Getting Started

Assembly Steps

Instructions for unpacking, identifying parts, and assembling the grill components.

Tools Required for Assembly

List of tools needed for assembling the grill.

Hose Connection Procedures

Propane Hose Connection

Correctly connecting the propane hose to the grill for safe operation.

Natural Gas Hose Connection

Correctly connecting the natural gas hose to the grill for safe operation.

Parts List

Parts List (365 SIB)

List of parts specific to the 365SIB model.

Napoleon ROGUE 365 Specifications

General

Main Burners	2
Fuel Type	Propane
Side Burner	No
Material	Stainless steel
Infrared Rear Burner	No
Grill Grates	Porcelain-coated cast iron
Ignition System	JETFIRE ignition system
Primary Burner	Stainless Steel
Grill Dimensions	48 x 25 x 47.5 inches
Warranty	15-year limited warranty