EasyManua.ls Logo

Nexgrill 740-0593A - User Manual

Nexgrill 740-0593A
24 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
ITEM / ARTICLE / ARTICULO # 296473
STAINLESS STEEL LP BUILT-IN
GRILL
MODEL / MODÈLE / MODELO # 740-0593A
Example only: SERIAL # ________ MFG. DATE ________ PURCHASE DATE: _________
Questions, problems, missing parts? Before returning to your retailer, call our customer
service department at 1-877-323-5263, 8 a.m. - 6 p.m., PST, Monday - Friday, 8 a.m. – 12 p.m.
Saturday.
®
WARNING
To reduce the risk of fire, burn hazard or other
injury, read the Care and Use Manual carefully
and completely before using your grill.
WARNING
FOR OUTDOOR USE ONLY
WARNING
This grill is not intended to be
installed in or on recreational
vehicles and/or boats.
T
M
T
M
WARNING
1. Do not store or use gasoline or other
flammable liquids or vapors in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
Figure 2240
CSA International
Project 2056659
2 of 25

Table of Contents

Questions and Answers

  • C
    Courtney VanceJul 31, 2025
    What to do if my Nexgrill 740-0593A won't light?
    • M
      Meredith JohnsonJul 31, 2025
      First, push and turn the knob to see if there's a spark. If you see a spark, ensure gas is reaching the burner. You may need to purge the gas line to remove trapped air. Try match-lighting the burner to check gas flow. Also, check if other burners are working. Inspect the electrode and wire while pushing the igniter knob; if the spark isn't at the igniter tip, the igniter needs replacing.
  • M
    Melissa CunninghamAug 4, 2025
    Why is my Nexgrill Grill producing low heat with LP gas?
    • T
      Taylor StevensAug 4, 2025
      Rapid pressure changes can activate the excess flow device. To resolve this, ensure all burner valves are in the “OFF” position. Then, open the tank valve and wait 5 seconds. Finally, light the burners one at a time, following the lighting instructions on the control box.
  • A
    andersonjohnAug 9, 2025
    How to prevent excessive flare-ups on my Nexgrill Grill?
    • J
      Joshua AndrewsAug 10, 2025
      To minimize flare-ups when using your Nexgrill Grill: * Keep the hood up while grilling. * Use low knob settings. * If needed, turn off one burner. * Preheat the grill for 10-15 minutes to burn off drippings. * Choose leaner meats. * When grilling chicken, start meat-side down on low for 20 minutes, then skin-side down for another 20 minutes, following the above steps. * If flare-ups persist, move food to the warming rack until the flames subside. Never spray water on gas flames, as this can damage your grill.
  • A
    Amy DouglasAug 15, 2025
    Why is my Nexgrill 740-0593A generating low heat even with the knob in the 'HI' position?
    • T
      tnunezAug 15, 2025
      First, determine if the issue is isolated to a single burner. If so, clean the orifice and burner, clearing any obstructions from the ports. Inspect the fuel hose for bends or kinks. Ensure the air shutter is properly adjusted and that the gas supply and pressure are adequate. Preheat the grill for a full 15 minutes. If you're using LP gas, check if the tank is empty.
  • Z
    zhuynhAug 20, 2025
    Why is the burner flame yellow and why do I smell gas on my Nexgrill 740-0593A Grill?
    • G
      ghillAug 20, 2025
      A yellow burner flame and gas odor indicate a potential issue. Inspect the burner inlet for obstructions, especially spiders or insects. Check the air shutter to ensure it's properly adjusted. Also, try to identify the source of any gas leaks.
  • J
    Jacob AlvarezAug 25, 2025
    What to do if the burner keeps blowing out on my Nexgrill Grill?
    • B
      Brian CoxAug 26, 2025
      If the burner on your Nexgrill Grill keeps blowing out, check for any defects in the burner itself and ensure it's installed correctly. Make sure the fuel mixture isn't too lean and that the gas supply is sufficient. Also, check to see if the LP tank is empty.

Summary

SAFETY INFORMATION

RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS

Explanation of safety symbols and warnings used in the manual.

INSTALLATION INSTRUCTIONS

CONNECTING THE LIQUID PROPANE CYLINDER

Detailed steps for safely connecting the LP cylinder to the grill.

LEAK TESTING

Method for checking gas connections for leaks before operation.

OPERATING INSTRUCTIONS

Lighting Instructions

Step-by-step guide for lighting the grill burners.

Gas Conversion From LP to NG

Natural Gas Conversion

Overview of converting the grill from LP to Natural Gas.

CARE AND MAINTENANCE

Flame Characteristics

How to check and adjust burner flame for optimal performance.

TROUBLESHOOTING

Grill will not light

Solutions for when the grill fails to ignite.

Burner flame is yellow and gas odor can be smelled

Troubleshooting steps for yellow flames and gas odor.

Excessive flare-ups

Methods to manage and prevent excessive flare-ups during grilling.

Burner blows out

Causes and solutions for burners that extinguish during use.

Low heat, LP gas

Low heat, natural gas

Low heat generated with knob in HI position

LIMITED WARRANTY

Nexgrill 740-0593A Specifications

General IconGeneral
TypeGas Grill
Fuel TypeLiquid Propane
Number of Burners4
MaterialStainless Steel
Side BurnerYes
Total BTU48, 000 BTU
Ignition SystemElectronic Ignition
Side Burner BTU12, 000 BTU
Warranty1 year limited

Related product manuals