Nokia 6500 SLIDE RM-240 - RF Self Tests and General Procedures

146 pages

To Next Page

To Previous Page

RF self tests in Phoenix

Context

Always start the troubleshooting procedure by running the Phoenix self tests. If a test fails, please follow the

diagram below.

Troubleshooting flow

RM-240

RF troubleshooting

Issue 1 COMPANY CONFIDENTIAL Page 4 –5

Main Page

Table of Contents15
Product Selection17
Phone Features17
Figure 1 RM-240 (Nokia 6500 Slide) Product Picture17
User Interface and Software Features18
Accessories18
Table 1 Battery and Chargers18
Technical Specifications19
General Specifications19
Battery Endurance19
Table 2 Car Accessories19
Table 3 Headsets19
Table 4 Data Cables19
Table of Contents23
Service Devices25
Product Specific Devices25
General Devices26
Fls-4S28
Cables33
Ca-28Ds34
Ca-31D34
Ca-35S34
Ca-89Ds35
Ca-92U35
Dau-9S35
Service Concepts37
POS (Point of Sale) Flash Concept37
Flash Concept with FPS-1038
Flash Concept with FPS-1039
Module Jig Service Concept40
Baseband Self Tests in Phoenix49
Power and Charging Troubleshooting51
Dead or Jammed Device Troubleshooting51
General Power Checking53
Charging Troubleshooting54
Interface Troubleshooting55
Flash Programming Fault Troubleshooting55
Combo Memory Troubleshooting58
SD Card Troubleshooting59
USB Interface Troubleshooting60
SIM Card Troubleshooting61
TV out Troubleshooting62
User Interface Troubleshooting63
Keypad and Side Keys Troubleshooting63
Display Module Troubleshooting65
General Instructions for Display Troubleshooting65
Blank Display Troubleshooting66
Faulty Image Troubleshooting67
Display on but no Image Troubleshooting69
Display Backlight Troubleshooting70
Hall Sensor Troubleshooting71
Camera Module Troubleshooting72
Introduction to Camera Troubleshooting72
Back (Main) Camera Troubleshooting72
Taking and Evaluating Test Pictures with Main Camera72
Camera Hardware Troubleshooting73
Camera Hardware Troubleshooting74
Small (Front) Camera Troubleshooting75
Evaluating Videocall Picture Quality from Small (Front) Camera75
Small (Front) Camera Bad Image Quality Troubleshooting76
Small (Front) Camera Troubleshooting77
Small (Front) Camera Hardware Troubleshooting78
LED Camera Flash Troubleshooting79
Audio Troubleshooting79
Audio Troubleshooting Test Instructions79
Internal Earpiece Troubleshooting84
Internal Microphone Troubleshooting85
Internal Handsfree (IHF) Troubleshooting86
External Earpiece Troubleshooting87
External Microphone Troubleshooting88
Vibra Troubleshooting89
Baseband Manual Tuning Guide89
Certificate Restoring for BB5 Products89
Energy Management Calibration95
RF Self Tests in Phoenix101
General RF Troubleshooting102
Introduction to RF Troubleshooting102
RF Key Components102
Non-Replaceable RF Components103
Auto Tuning for BB5.0104
General Voltage Checking105
Receiver Troubleshooting108
Introduction to Receiver (RX) Troubleshooting108
GSM RX Chain Activation for Manual Measurements/Gsm RSSI Measurement108
WCDMA RX Chain Activation for Manual Measurement/Wcdma RSSI Measurement109
Transmitter Troubleshooting110
General Instructions for Transmitter (TX) Troubleshooting110
GSM Transmitter Troubleshooting110
WCDMA Transmitter Troubleshooting113
Bluetooth and FM Radio Troubleshooting114
Bluetooth Troubleshooting114
FM Radio Troubleshooting115
Introduction121
Phone Description121
Energy Management126
Battery and Charging126
Normal and Extreme Voltages127
Power Key and System Power-Up127
Modes of Operation128
Clocking Scheme128
USB, SIM, Μsd, TV out129
Micro USB129
TV out129
SIM Interface130
Μsd Card Interface131
Camera Concept131
User Interface132
Display Module132
Keyboard and Other Keys132
Backlight and Illumination133
Ambient Light Sensor (ALS)133
Slide Switch133
Audio Concept134
Audio135
AV Connector135
RF Description136
Bluetooth136
FM Radio136
Receiver (RX)137
Transmitter (TX)138
Technical Specifications138
Main RF Characteristics for GSM and WCDMA Band Phones138
Environmental Conditions140

Nokia 6500 SLIDE RM-240 - RF Self Tests and General Procedures

Table of Contents