Operating Instruction and Documentation
MCS 5500 ND WIRELESS
- 2 -
Contents
Foreword ................................................................................................................. 3
Record of handing over ........................................................................................... 5
1.Introduction .............................................................................................................. 6
1.1 Installation and check of the automotive lift ....................................................... 6
1.2 Information of Warning ...................................................................................... 6
2.Master document of the MCS 5500 ND WIRELESS ............................................... 7
2.1 Lift–manufacturer ............................................................................................... 7
2.2 Application ......................................................................................................... 7
2.3 Changes at the construction .............................................................................. 7
2.4 Declaration of conformity ................................................................................... 8
3.Technical Information .............................................................................................. 9
3.1 Technical ratings................................................................................................ 9
3.2 Safety device ................................................................................................... 10
3.3 Data sheet ....................................................................................................... 11
4.Safety regulations .................................................................................................. 12
5.Operating instructions ............................................................................................ 14
5.1 Positioning of the columns ............................................................................... 14
5.2 Putting into operation ....................................................................................... 15
5.3 Lifting the vehicle (mode synchronous) ........................................................... 16
5.4 Lowering the vehicle (mode synchronous) ...................................................... 18
5.5 Single-Mode „Lifting“ ........................................................................................ 19
5.6 Single-Mode „Lowering“ ................................................................................... 20
5.7 Axle-mode (only with 6 columns) ..................................................................... 21
5.8 Equalisation of the MCS .................................................................................. 22
6.Troubleshooting ..................................................................................................... 23
6.1 Lowering on a obstacle .................................................................................... 24
6.1.1 Remove the obstacle ................................................................................. 24
6.2 Emergency lowering ........................................................................................ 24
6.2.1 Procedure of the emergency lowering ....................................................... 24
6.3 Reset the MCS after an emergency lowering .................................................. 26
7.Inspection and Maintenance .................................................................................. 27
7.1 Maintenance plan of the Mobile column lift ...................................................... 27
7.2 Cleaning of the Mobile column lift .................................................................... 29
8.Security check ....................................................................................................... 30
9.Handing over and Initiation .................................................................................... 31
9.1 Regulations ...................................................................................................... 31
9.2 Initiation ........................................................................................................... 31
9.3 Position of the columns .................................................................................... 32
First security check before installation ................................................................... 33
Regular security check and Maintenance .............................................................. 34
Extraordinary security check .................................................................................. 42
Hydraulic diagram drawing .................................................................................... 43
Electrical diagram drawing ..................................................................................... 45
To Next Page
Loading...