Nyle C Series - Service Log

44 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

36

Service Log

Issue Description

Date Servicer

Table of Contents

Default Chapter3
- Table of Contents3
Safe Installation, Use and Service5
General Safety Information6
- Precautions6
- Grounding Instructions6
Introduction7
- Qualifications7
- Preparing for the Installation7
- Principle of Operation8
- The Refrigeration Cycle8
- Source Water Temperature Range8
- Water Temperature Range8
- Refrigerant Charge8
- Equipment Disposal8
Features & Components9
- Product Illustration9
- Water to Water Cycle10
- Rough in Dimensions11
- Performance Specifications11
Installation Requirements12
- Water Temperature12
  - Maximum System Temperature12
  - Inlet & Outlet Water Temperature12
- Source Water Temperature12
  - Entering Source Water Temperature12
- Locating the Water Heater12
- Clearances13
- Electrical Requirements13
  - Minimum Wire Size14
- Water Piping15
- Water Pressure15
- Closed Water Systems15
- Thermal Expansion15
- Mixing Valves15
- Contaminated Water16
- Temperature-Pressure Relief Valve16
- Tank Selection16
  - Solar Tanks16
- Storage & Handling16
  - Storage Recommendations17
Installation17
- Required Ability17
- General17
- Required Tools & Materials17
  - Installation & Start up Tools17
  - Service Tools18
- Unit Placement18
  - Mounting Frame18
  - Pad Mounting18
- Electrical Connections18
- Water Connections19
  - Installation Instructions19
- Single Tank Configuration19
- Multiple Tank Configuration20
- Standard Tank Thermostat20
- Temperature Sensor Installation20
Installation Checklist20
- Location20
- Water Piping20
- Electrical21
- Pre-Startup Checklist21
- Phase Startup Procedures21
- Single Phase Startup Procedures22
- Initial Start-Up22
- Master Control Panel Pre-Startup Checklist22
- Rotation Direction23
- Starting Sound23
Start up23
Setting Lower Limit Control Valve Limit for Single-Pass24
- Purging the Condenser on a Plc24
Electronic Temperature Controls24
- Controller24
- Function Ranges & Settings25
  - Parameter Settings25
- Screen Navigation25
- Basic Mode25
- Advanced Mode25
- Restricted Mode26
Programmable Logic Controls26
- Plc Controller26
- Temperature & Setpoints26
  - Setpoints Ranges & Safeties26
Master Screens27
- Master Panel Home Screen27
- Master Panel Alarm Screen27
- Master Panel Configuration Screen27
Master Screen Terminology27
- Home Screen27
- Alarm Screen27
- Configuration Screen27
- Master Control Panel Setup to Member Units28
- Master Control Unit Support Call Sequence of Operations28
Member Screens28
- Single Unit Home Screen Operating with Master Controls28
- Single Unit Home Screen Operating as Asingle Unit (in Defrost)28
- Single Unit Home Screen Displaying Alarm28
- Single Unit Alarm Screen29
- Single Unit Configuration Screen29
Member Screen Terminology29
- Home Screen29
- Alarm Screen29
- Configuration Screen29
Stop Screen30
Ip Configuration30
Maintenance and Service30
- Routine Maintenance30
- Cleaning Internal Insulation30
- Checking Refrigerant Charge30
- Check Water Temperature Rise31
- Factory Charge31
- Superheat Calculation31
- Braze Plate Cleaning Instructions31
Troubleshooting32
Water Piping Diagrams33
Limited Warranty38
Service Log40

Related product manuals

Preview: Nyle e360

Preview: Nyle C25W